Scan Manual ALP CL 32 S [PDF]

Zitiervorschau

QC-200-S-005-1701

AUTOCLAVE (Steam Sterilizer)

CL- 325 132L 405 140M I 40L Instruction Manual

• •

Make sure to read this manual to use this product safely . Place this manual in a convenient location for easy reference.

ALP Co.,Ltd. Tokyo Japan

E

Contents notes

P.3

2. For the safety use

P.3 to 6

3. Part names

P.7 to 8

4. Installation

P.9 to 15

1. Preliminary

5. Operation

P.16 to 38

method

P.39

6. Safety device 7. Trouble shooting

P.40 to 43

8. Maintenance

P.44 to 51 P.52

9. Specifications 10. Disposal and dismantlement

P.53 P.54 to 56

11. Appendix

2

1. Preliminary notes

:.

•

Thank you for choosing ALP products. Keep this manual at your hand for your quick reference whenever operating this autoclave.

•

Do not use this autoclave for improper purpose. Strict observance of this manual is required.

•

Please do understand and observe safety instructions written in this manual. Failure to follow safety instructions may cause trouble and I or death.

•

Following documents are attached to this autoclave. Please check and if some of them are missing, contact local distributor. • Instruction Manual • Certificate of Quality

•

The lid is not opened until putting the power on. (Refer to 4. 4 Power cable connection and protective

:.

grounding)

2. For the safety use Preamble Autoclave is being operated with high temperature and high pressure. Wrong installation and lor failure to observe safety operation according to the instruction manual may cause death or injury of operator and I or person near the autoclave, and I or destruction of things. Please read this chapter carefully then operate this autoclave. Important statements are illustrated as follows. Please understand each meaning and observe these cautions. The meaning of each illustration

.& WARNING .& CAUTION (S)

o

:Failure

is as follows;

to this warning may cause death or serious injury of person .

.Fallure to this caution may cause injury and things.

Prohibited Strictly Observed 3

I

or destruction

of

.

•

How to use autoclave

&WARNING

o

o o o o

This autoclave sterilizes objects with high temperature and high pressure. Do not operate putting following materials and I or dangerous substances (Refer to 11.3 Dangerous substances list) in chamber . • Explosive materials •Flammable materials • Acid or Alkaline materials •Corrosive materials •Non heat-resistance materials In case of sterilization of saline objects such as seawater, discharge saline water after sterilization. Then put fresh water and operate several times without load. If you spill saline objects, be sure to wipe off. Failure to do them may cause explosion due to corroded chamber and pipes.

Do not disassemble and I or modify autoclave. Autoclave being pressure vessel. disassemble and I or modification of autoclave may cause accident and I or breakage.

Do not move autoclave holding lid nor push it hard. Lid may jolt out of alignment which leads to serious accident and

I or trouble.

Do not get autoclave wet. If electric component get wet, it may be broken. get a shock. and even cause fire.

•

Installation

&WARNING

o o

o

Do not use power strip. (Refer to 4. 4 Power cable connection and protective grounding) If power cable is bundled or tangled and lor wrongly connected. these may cause fire and I or get a shock. Protective grounding conductor must be connected to protective grounding terminal. Connection to gas pipe or water pipe may cause explosion. get a shock and lor breakage. Do not install autoclave in the place where chemicals such as flammable materials, explosive materials, and lor corrosive gas are kept. Installing autoclave in above mentioned place may cause serious accident and/or trouble of autoclave.

&CAUTION

o o •

This autoclave should be used indoors. Do not install it outdoors. and/or breakage of autoclave if it is used outdoors. This autoclave must be installed on level and hard floor. Installation without stability may cause malfunction and lor trouble. There are many possibilities of malfunction

Cleaning

&WARNING

o

Do not use cleaning products for cleaning the inside of the chamber. It may cause explosion due to corroded metallic parts.

&CAUTION

o

o

Do not use liquid which corrode metal and/or paint (EX. thinner, hypochlorous acid, chlorine dioxide, acetyl hydroperoxide) for cleaning the exterior. Metallic parts may corrode.

Do not splash chlorine chemical and/or cleaning products (EX. hypochlorous acid, chlorine dioxide, acetyl hydroperoxide) to the exterior during cleaning the floor. Metallic parts may corrode.

4

-

• Notes on the operation

~WARNING

o

o o

Be sure to close lid to prevent pinching dusts before operation. If there is something between lid and chamber which prevents lid from closing, the lid may burst at high pressure which cause fatal accident or serious injury. Then operator may get burned by steam leaked from chamber.

Be sure to slide lid lock lever slowly to close position (left end) before operation. If lock is not enough, operator can not start operation (Er4 is shown). But if operator can start operation by malfunction of detection part, lid may explode at high pressure which cause fatal accident or serious injury.

Objects (including disposable plastic bag) must be put in stainless wire basket or stainless bucket when sterilization. If operator loads objects into chamber directly, it may cause choking pipes which may lead to serious accident.