35 3 9MB
Parts Manual Generator Set with PowerCommand 3201 Controller
DQFAA (Spec A−E) DQFAB (Spec A−E) DQFAC (Spec A−E) DQFAD (Spec A−E)
English Original Instructions
12-2013
961−0211 (Issue 10)
To avoid errors or delay in filling your parts order, always give the MODEL, SPEC NO. and SERIAL NO. from the Cummins Power Generation nameplate. For handy reference, insert your nameplate information in the spaces below.
MODEL AND SPEC NO. SERIAL NO. DIGITAL CONTROL SOFTWARE VERSION AND DATE (IF APPLICABLE)
The following symbols are used in Cummins Power Generation manuals to alert users to the potentially dangerous conditions relating to maintenance of equipment and replacement of parts. Please read and observe. This symbol warns of immediate hazards which will result in severe personal injury or death. This symbol refers to a hazard or unsafe practice which can result in severe personal injury or death. This symbol refers to a hazard or unsafe practice which can result in severe personal injury or product or property damage.
Service and repair of Cummins Power Generation equipment must be performed by trained, experienced personnel only. Improper service or repair may result in property damage, severe personal injury or death. Do not use this catalog as a guide to servicing your equipment. Read and follow the IMPORTANT SAFETY INSTRUCTIONS in the Service Manual appropriate for the equipment you are working on.
Contact with USED ENGINE OILS has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When checking or changing engine oils take all necessary precautions not to ingest, breathe the fumes or contact the used oil.
Contact with ASBESTOS has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When handling engine gaskets take all necessary precautions not to ingest, breathe or contact the dust from the gaskets! Use adequate ventilation and wear protective gloves, masks and clothing!
Contact with BENZINE and LEAD, found in gasoline, fuel additives and solvents has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When checking, draining or adding gasoline and fuel additives or using solvents take all necessary precautions not to ingest, breathe the fumes or contact the liquids. Use adequate ventilation and wear protective gloves, masks and protective clothing! PSP-1
Introduction This Parts Catalog applies to Cummins Power Generation Generator Models DQFAA, DQFAB, DQFAC and DQFAD as listed in the Generator Set Data Table. Parts are arranged in groups of related items and each illustrated part is identified by a reference number corresponding with the same reference number in the parts list. Parts illustrations are typical. Unless otherwise mentioned in the description or page heading, parts are interchangeable between models. Throughout this catalog left and right sides are determined by facing the engine end (front) of the set. Engine parts that have been modified or added by Cummins Power Generation are identified in this catalog. All other Engine replacement parts must be ordered from the engine manufacturer by referring to the engine manufacturers nameplate and supplying all available information. Contact your nearest engine parts distributor for assistance in ordering replacement parts.
Replacement Engine Cummins Generator Model
Cummins Engine Model
750 DQFAA
QST30−G5
800 DQFAB
QST30−G5
900 DQFAC
QST30−G5
1000 DQFAD
QST30−G5
Generator Set Data Table Model/ Specification S ifi ti
Electrical Data Volts
Hertz
Wire
Phase
Battery Voltage V lt
750 DQFAA/*
#
60
6 or 12
3
24 VDC
800 DQFAB/*
#
60
6 or 12
3
24 VDC
900 DQFAC/*
#
60
6 or 12
3
24 VDC
1000 DQFAD/*
#
60
6 or 12
3
24 VDC
* − The diagonal line (/) in the model and specification number separates generator set characteristics from the specification number and letter. The specification number denotes customer requested options or deviations from the Standard model. The specification letter advances with major manufacturing changes. # Broad Range Reconnectible.
1
A Alarm, Overfill, 9
B Band, Mounting − Air Cleaner − Heavy Duty, 7 Band, Mounting − Air Cleaner − Standard, 6 Block, Terminal − Engine Coolant Heater Control, 18 Box, AC Circuit Breaker, 96 Box, Control, 49 Box, Control − Engine Coolant Heater, 18 Box, Control − Installation, 45 Box, Control − Mounting, 44 Box, Entrance, 36 Box, Terminal − Generator Heater, 41 Bracket, Guard − 50DEGC Ambient Radiator, 24 Bracket, Guard − Remote Radiator, 22 Bracket, Mounting − Radiator − 50DEGC Ambient Radiator, 24 Bracket, Radiator Support − 50DEGC Ambient Radiator, 24 Breaker, Circuit − NSJ 600 Amp, 60 Breaker, Circuit − P−Frame 800−1200 Amp, 62 Breaker, Circuit − R−Frame 1600−2500 Amp, 64
C Cable, Battery, 5 Cage, Card − Control, 50 Cap, Radiator − Heat Exchanger, 20 Cartridge, Heater − Generator Heater, 41 Charger, 15 Amp − Mounting, 97 Cleaner, Air − Heavy Duty, 7
Cover, Muffler − Weather − Aluminum Enclosure, 91 Cover, Muffler − Weather − Steel Enclosure, 77
D Door, Control, 48 Duct, Air − DQFAA, DQFAB, DQFAC, 99 Duct, Air − DQFAD, 100
E Enclosure − Aluminum, 32 Enclosure − Steel, 28 , 30 Exchanger, Heat, 20 Exhaust − Sound, 13 Exhaust − Weather, 12
F Fan, Engine − 50DEGC Ambient Radiator, 24 Floor − Installation, 81
G Generator (Complete Replacement Part Numbers), 42 Generator Mounting − Model HC6 Generator, 39 Generator Mounting − Model P7 Generator, 40 Guard, Alternator − Remote Radiator, 22 Guard, Belt − Remote Radiator, 22 Guard, Fan − 50DEGC Ambient Radiator, 24 Guard, Front − Remote Radiator, 22 Guard, Top − Remote Radiator, 22
H
Cleaner, Air − Standard, 6
Harness, Wiring − AC, 66
Control, Engine Coolant Heater, 18
Harness, Wiring − Control, 66
Cover, Battery, 102
Harness, Wiring − DC − Engine Coolant Heater Control, 18
Cover, Muffler − Sound − Aluminum Enclosure, 94 Cover, Muffler − Sound − Steel Enclosure, 80
Harness, Wiring − Engine to Control, 68 Harness, Wiring − Extension, 67
Heater, Control, 46 Heater, Coolant, 16 Heater, Generator, 41 Hose, Radiator − 50DEGC Ambient Radiator, 24 Hose, Radiator − Heat Exchanger, 20 Housing, Control − Model HC6 Generator, 37 Housing, Control − Model P7 Generator, 38
R Radiator − 50DEGC Ambient, 24 Radiator − Service Parts, 25 Radiator, Remote, 22 Receptacle, External, 98 Rectifier, Silicon − Engine Heater Wiring Harness, 18 Relay, Alarm, 53
I Indicator, Service − Air Cleaner − Heavy Duty, 7 Indicator, Service − Air Cleaner − Standard, 6
Relay, Customer, 53 Relay, Ground Fault, 57 Relay, Power − Engine Coolant Heater Control, 18 Relay, Run, 53
L Labels, Circuit Breaker, 65 Labels, Miscellaneous, 104
S Sealant, Thread, 4
Lighting, Enclosure, 82
Sender, Low Coolant Level, 14
Louver − Level 1 and 2 − Aluminum Enclosure, 86
Socket, Relay, 53
Skid, 33 , 34 , 35
Louver − Level 1 and 2 − Steel Enclosure, 76
Switch, Emergency Stop, 69
Louver − THOR2, 90
Switch, Key Operator, 101
Louver, Actuator, 84
Switch, Trip Alarm or Auxiliary Contact − Circuit Breaker, 64
Louver, Inlet − Components − Weather − Steel Enclosure, 74 Louver, Inlet − Weather − Aluminum Enclosure, 88 Louver, Inlet − Weather − Steel Enclosure, 72 Louver, Outlet − Auto, 84
M
System, Mounting, 83
T Tank, Expansion − Heat Exchanger, 20 Tank, Fuel, 10 , 11 Transformer, 24VAC, 70 Transformer, Current, 51
Module, Audible Alarm, 56
Trip, Shunt − Circuit Breaker, 64
Module, Bus PT, 55
Tube, Radiator Inlet − 50DEGC Ambient Radiator, 24
Module, PT/CT, 52
P Parts, External Engine, 5
Tube, Radiator Outlet − 50DEGC Ambient Radiator, 24
V
Pump, Fuel, 95
Valve, Gate − Heat Exchanger, 20
Pyrometer, 54
Valve, Thermostatic, 20
Abbreviations
Some of the following abbreviations may be used throughout this Parts Catalog: AC Amp A/R AVR AWG CSA
Alternating Current Ampere As Required Automatic Voltage Regulator American Wire Gauge Canadian Standard Association Direct Current Degree Electronic Fuel Control External/Internal Tooth Erasable Programmable Read Only Memory External Tooth Ground Fault Interrupter Inside Diameter International Electrotechnical Commission Internal Tooth Kilowatt Liquid Petroleum Gas Left Meter
DC Deg. EFC EIT EPROM ET GFI ID IEC IT kW LPG LT M(meter number)
MCM mm MOH NFS NPT OD oz. PC Ph PMG PT/CT
Metric Circular Mils Millimeter Mobile Off Highway Not For Sale National Pipe Thread Outside Diameter Ounce Printed Circuit Phase Permanent Magnet Generator Potential Transformer/ Current Transformer Radio Frequency Interference Right Specification Thick Underwriters Laboratories Inc. Union National Coarse Union National Fine Volts Alternating Current Volts Direct Current With
RFI RT Spec Thk UL UNC UNF VAC VDC W/(ET, IT, EIT)
Paint and Thread Sealant
REF NO.
PART NO.
QTY USED
525−0305
−
525−0306 525−0304
− −
PART DESCRIPTION
REF NO.
Onan Green Enamel (Non-Metallic) 12 oz. Pressurized Spray Can Quart Can Gallon Can
4
PART NO.
QTY USED
518−0601
−
PART DESCRIPTION Sealant, Thread (6 ml. Tube)
External Engine Parts
12 15 17
19
12 15 17
14
12 13 16
2 3 4
11 15 17
12
6 5 1
2 3 4
18
7 8 10
9
REF NO. 1 2 3 4 5 6 7 8 9 10 11
PART NO.
QTY USED
505−1508 505−0102 504−0171 505−0324 416−0639 416−1096 319−2236 402−0729 305069200 870−2054 856−0010
1 2 2 2 2 1 1 2 1 4 1
PART DESCRIPTION
REF NO.
Adapter (M27 to 3/4) Nipple, Close (3/4) Valve, Shut Off Nipple, Half (2”) Cable, Battery Cable, Jumper Bracket, Pilot − Solenoid Isolator, Vibration Solenoid, Pilot Nut, Lock − Flange (M6 x 1.0) Washer, Lock − EIT (3/8”)
5
PART NO.
QTY USED
12 13
327−0923 800−2110
12 2
14
416−0680
3
15
800−2085
10
16 17 18 19
526−2140 2 526−2120 10 416−1019 1 130−6291−02 1
PART DESCRIPTION Clamp, “J” Screw, Cap − Hex Head (M12 x 1.75 x 20) Cable, Battery − Starters and Engine Ground Screw, Cap − Hex Head (M10 x 1.5 x 20) Washer, Flat (M12) Washer, Flat (M10) Boot, Battery − Red Bracket, Tube − Conduit
Air Cleaner Standard 5 7
15
5 7
9
15
15 12
13
15
14
8
6
9 15 1
10
11 15
4
3
2
6
8
17 16 19 18 REF NO.
PART NO.
QTY USED
1 2 3 4 5 6
503−1870−10 2 140−3993−02 1 140−3994−02 1 140−3990−02 1 140−2502 4 821−6003−02 18
7
140−3163
2
8 9 10
503−2102 503−0970 870−0557
2 2 8
PART DESCRIPTION
REF NO.
Clamp, Hose Bracket, Air Cleaner − Right Bracket, Air Cleaner − Left Base, Air Cleaner Band, Mounting Screw, Hex Head (M8 x 1.25 x 20) Cleaner, Air (No Replaceable Element) Elbow, Reducer − 90 (7 x 5.5) Elbow Nut, Hex − Flange (M8 x 1.25)
6
PART NO.
QTY USED
11 12 13 14 15 16 17
130−7026−02 130−7078 140−1260 140−1548 503−1870−14 526−2140 800−3017−52
1 1 2 2 6 4 4
18 19
850−2020 800−2201
4 4
PART DESCRIPTION Tube, Air Tube, Air Fitting − Safety Filter Indicator, Service Clamp, Hose Washer, Flat (M12) Screw, Cap − Hex Head (M12 x 1.75 x 20) Washer, Lock − Split (M20) Screw, Cap − Hex Head (M20 x 2.5 x 35)
Air Cleaner Heavy Duty (8” Outlet) 10
11 5
11
21
10 5
6
21
19 20 9 8
14
12
4 3
6
13 7 19
22
14
1
12 4
2
16
13
15
18
17 REF NO.
PART NO.
QTY USED
1 2 3 4 5
140−3993−02 140−3994−02 140−3990−02 503−2102 140−2097
1 1 1 2 2
6 7
140−2096 140−2467 503−1485 130−7078
− − 2 1
8 9 10 11 12
140−1260 2 140−1548 2 140−2099 4 140−2098 2 821−6003−02 18
PART DESCRIPTION
REF NO.
Bracket, Air Cleaner − Right Bracket, Air Cleaner − Left Base, Air Cleaner Elbow, Reducer − 90 (7 x 5.5) Cleaner, Air Replacement Element Primary Safety Elbow, Hose − 90 (8” to 7”) Tube, Air − Right and Left Top Entrance Box Fitting − Safety Filter Indicator, Service Band, Mounting Hood, Air Inlet Screw, Hex Head (M8 x 1.25 x 20)
7
PART NO.
QTY USED
13 14 15 16
503−1870−11 503−1870−14 526−2140 800−3017−52
2 4 4 4
17 18
850−2020 800−2201
4 4
19
130−7026−01
1
20
130−7026−02
1
21 22
503−1870−16 870−0557
2 8
PART DESCRIPTION Clamp, Hose Clamp, Hose Washer, Flat (M12) Screw, Cap − Hex Head (M12 x 1.75 x 20) Washer, Lock − Split (M20) Screw, Cap − Hex Head (M20 x 2.5 x 35) Tube, Air − Right and No Top Entrance Box Tube, Air − Left and No Top Entrance Box Clamp, Hose Nut, Hex − Flange (M8 x 1.25)
Air Cleaner Heavy Duty (10” Outlet) 15 18 14
12, 24
20
19, 25 16
15 18
17
14
10 12, 24 17
23
19, 25 16
20
21
10
13, 24
3
4, 24
22
1
5 23
6, 7
2
11
13, 24 5 4, 24 REF NO. 1 2 3 4 5 6 7 8 9 10 11 12 13
PART NO.
QTY USED
A029H251 1 A029H247 1 A029H255 1 503−1870−11 2 503−2102 2 536−2140 4 800−3017−52 4 850−2020 4 800−2201 4 503−1485 2 821−6003−02 10 503−1870−16 4 503−1870−14 4
8 9
PART DESCRIPTION
REF NO.
Bracket, Air Cleaner − Right Bracket, Air Cleaner − Left Plate, Air Cleaner Clamp, Hose Elbow, Reducer Washer, Flat Screw, Hex Head Washer, Lock Screw, Hex Head Elbow, 90 Dregree Screw, Hex Head Clamp, Hose Clamp, Hose
14 15 16 17 18 19 20 21 22 23 24 25
8
PART NO.
QTY USED
A034R952 2 A029G975 4 A029G977 2 A029G313 2 140−3370 2 A029J872 2 A029K623 2 821−5004−02 8 870−0550−09 8 A029H243 2 503−2823 10 A084Z634 2
PART DESCRIPTION Filter, Air Strap, Air Filter Hose, Air Tube, Induction Cap, Rain Clamp, Hose Sensor, Pressure Screw, Hex Head Nut, Hex − Flange Tube, Air Filter Clamp, Hose Clamp, Hose
Overfill Alarm
12
2
1
6 6
10
4
9 3
13
7 5 8
REF NO.
1 2 3 4 5
4
11
PART NO.
QTY USED
PART DESCRIPTION
REF NO.
333−0683−02
1
6 7 8
319−5056−02 333−0682 307−2817−02 526−0399−05 815−0937
1 1 1 9 1
Alarm − Assembly − 24VDC (Includes all the Following Except Two Mounting Screws) Box, Control Horn, Alarm Relay Washer, Flat Screw, Machine − Pan Head − Cross Recessed − W/ET (#6−32 x .50)
9 10 11 12 13
9
PART NO.
QTY USED
870−0183 518−0340 815−0651
5 1 4
508−1195 338−4360−02 098−8120 308−0973 815−0709−01
4 1 1 1 2
PART DESCRIPTION Nut, Hex − W/ET Clamp, Cable Screw, Machine − Pan Head − Cross Recessed − W/ET (#6−32 x .75) Grommet Harness, Alarm Label, Information Switch, Pushbutton Screw, Hex Head − Flange − Thread Forming (M8)
Fuel Tank
1
REF NO. 1
PART NO. A029Z634 A029Z638 A029Z639 A029Z640 A029Z642 A029Z643
QTY USED A/R A/R A/R A/R A/R A/R
PART DESCRIPTION
REF NO.
Tank 200 Gallon 660 Gallon 1000 Gallon 1500 Gallon 2000 Gallon 2400 Gallon
10
PART NO.
QTY USED
PART DESCRIPTION
Fuel Tank (Spec E)
1
REF NO. 1
PART NO. A040X443 A040X445 A040X446 A040X447 A040X449 A040X451
QTY USED A/R A/R A/R A/R A/R A/R
PART DESCRIPTION
REF NO.
Tank 200 Gallon 660 Gallon 1000 Gallon 1500 Gallon 2000 Gallon 2400 Gallon
11
PART NO.
QTY USED
PART DESCRIPTION
Exhaust Weather
16
2
10 11 4 7 9
1
12 16
8 16 3
6 13 11 14 15
5
REF NO.
PART NO.
QTY USED
PART DESCRIPTION
1 2 3 4 5 6 7 8 9
155−4313 155−4415−01 155−4396−02 155−4396−05 155−4317−02 155−4344 155−4382 155−4412−02 155−3543
1 1 1 1 2 2 2 2 2
Muffler (Weather and Level 1) Cap, Rain Pipe, Exhaust Pipe, Exhaust Pipe, Exhaust Flange, Exhaust Gasket, Muffler Hanger, Exhaust Clamp, Exhaust
REF NO.
12
PART NO.
QTY USED
10 11
526−0249−01 4 800−2089 20
12
821−5003−03
13 14 15 16
155−2351 2 850−2010 32 860−2009 16 155−4414−01 6
4
PART DESCRIPTION Washer, Flat (7/16) Screw, Cap − Hex Head (M10 x 1.5 x 40) Screw, Hex Head (5/16 x 18 x .75) Gasket, Exhaust Washer, Lock − Split (M10) Nut, Hex (M10 x 1.5) Clamp, Exhaust
Exhaust Sound
17
3
11 12
2
5
8
13 1
17 9 10 17 4
7 14
12 15 16
6
18 19
REF NO. 1 2 3 4 5 6 7 8 9 10 11
PART NO.
QTY USED
PART DESCRIPTION
155−4314 155−4315 155−4415−02 155−4396−05 155−4396−02 155−4317−02 155−4344 155−4382 155−4412−02 155−3543 526−0249−01
1 1 2 1 1 2 2 2 2 2 4
Muffler (Right Hand, Level 2) Muffler (Left Hand, Level 2) Cap, Rain Pipe, Exhaust Pipe, Exhaust Pipe, Exhaust Flange, Exhaust Gasket, Muffler Hanger, Exhaust Clamp, Exhaust Washer, Flat (7/16)
REF NO.
13
PART NO.
QTY USED
12
800−2089
20
13
821−5003−03
14 15 16 17 18 19
155−2351 2 850−2010 32 860−2009 16 155−4414−01 6 526−0128 6 800−2114 6
4
PART DESCRIPTION Screw, Cap − Hex Head (M10 x 1.5 x 40) Screw, Hex Head (5/16 x 18 x .75) Gasket, Exhaust Washer, Lock − Split (M10) Nut, Hex (M10 x 1.5) Clamp, Exhaust Washer, Flat (M12) Screw, Cap − Hex Head (M12 x 1.75 x 40)
Low Coolant Level Sender
2 4
5
3 7
8
6
1
REF NO.
PART NO.
QTY USED
1 2
193−0486 338−3832
1 1
3 4 5
323−1765 323−1708 323−1549
1 4 1
PART DESCRIPTION
REF NO.
Sender, Low Coolant Level Harness, Low Coolant Level (Includes Parts Marked *) *Housing, Connector (4 Pin) *Seal, Cable *Socket, Receptacle
6 7 8
PART NO. 323−1547 323−1491 323−1709
QTY USED 1 4 4
PART DESCRIPTION *Wedge, Receptacle *Terminal, Pin *Socket, Contact
* − Parts Included in 338−3832 Wiring Harness
14
Coolant Heater
10 8
6
13
19 16
15
15 19
7 40
9 4
37
41 14
42
31
17
26
4
14
37
19
27 28 29 30
35 4
18
1
19
34
31 4
26
22
5
11
2
19
4 1
2
36
20 27 35
4
32
32 33
21
32
19 31 33 35
12 22 23
31 33
25 24
3
15
31 33
4
38
39
Coolant Heater REF NO. 1
PART NO.
QTY USED
2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20
333−0677−01 2 333−0677−02 2 130−4546 2 319−4788−02 1 503−3062−01 7 130−6255−02 1 133−0226 1 502−0827 2 505−1576−02 2 504−0214 1 504−0215 1 A029C090 1 130−6256−02 1 130−6258−02 1 502−0827 2 504−0213 2 505−0100 2 505−0050 2 130−6257−02 1 503−2157−02 16 821−5004−03 4
21 22 23
155−3021 870−0550−09 526−0128
2 6 2
PART DESCRIPTION Heater, Water 4990 Watts 6420 Watts Bracket, Water Heater Cover, Control Hose, Silicone Rubber Tube, Water Heater Manifold, Heater Hose, Barb Nipple, Hex Pipe (1”) Valve, Ball (1”) Valve, Check (1/4”) Hose, Silicone Rubber Tube, Water Heater Tube, Water Heater Hose, Barb Valve, Ball Nipple, Pipe (1/2 x 1.13) Elbow, Street − 90 (1/2) Tube, Water Heater Clamp, Hose Screw, Hex Head (3/8−16 x 1.00) Clamp, Water Heater Nut, Hex − Flange (3/8−16) Washer, Flat
16
REF NO.
PART NO.
QTY USED
24 25
520−0544 821−5002−03
2 4
26
128−0108
−
27 28 29 30
518−0548−15 370−4038 850−0114−07 800−0054
4 4 2 2
31 32 33
518−0704 327−0923 821−5004−02
5 3 5
34 35
309−0649 821−6003−01
1 5
36 37 38 39 40 41 42
130−6260−02 503−2556−05 098−5347 098−6195 501−0744−10 502−1514 503−2519
2 3 1 1 1 1 1
PART DESCRIPTION Stud, Generator Mounting Screw, Hex Head (1/4−20 x .50) Insulation, Hose − Bulk (Order by the Foot − 7 Feet Required) Clamp, Hose Spacer Washer, Lock − Split (3/8) Screw, Cap − Hex Head (3/8−16 x 2.00) Clamp, “J” Clamp, “J” Screw, Hex Head (3/8−16 x .75) Thermostat Screw, Hex Head (M8 x 1.25 x 16) Bracket, Tube − Heater Clamp, Hose − CTB Label, Danger Label, Caution Hose Assembly Tee, Hose − Barbed Hose, Coolant
Engine Coolant Heater Control
14
19 18
15
20
23
17
22
3
30
13
21
16
2 12
29
11
8
2
24
7 1 31
10
4
6
5
25 26 27 28
9
17
32
Engine Coolant Heater Control REF NO.
PART NO.
QTY USED
1 2 3 4 5 6
319−4787−02 130−4552 331−0555 517−0138−02 332−1469 332−1468
1 2 5 2 1 1
7 8
307−2859 815−0447
1 5
9 10
332−3440 331−0042
2 1
11
338−4105−14
1
12
338−4105−15
1
13
338−4392
1
PART DESCRIPTION
REF NO.
Box, Terminal Cover, Coolant Heater Nut, Connector Lock (3/4−14) Plug, Hole (Fits 1−1/8” Hole) Strip, Marker Block, Terminal − 12 Place (TB1) Relay, Power − 24VDC Screw, Machine − Round Head − Cross Recessed − Thread Cutting − W/IT (#8−32 x .75) Jumper, Terminal Connector, Wiring − DC − Romex (3/4”) Harness, Heater − Engine − 42” (Includes 2 Conduit Connectors − 90 (3/4) (331−0554) Harness, Heater − Engine − 80” (Includes 2 Conduit Connectors − (1) 90 (3/4) (331−0554) and (1) (331−0570) Harness, Heater (Includes Parts Marked *)
PART NO.
QTY USED
14 15 16 17 18 19 20 21 22 23 24 25
357−0030 323−1491 323−1492 323−1494 323−1502 323−1504 323−1500 323−1652 323−1718 323−1445 307−2817−02 815−0203
1 3 4 1 1 2 2 1 2 2 1 1
26 27 28 29
871−0010 526−0049 870−0131 815−0539
1 2 1 6
30 31 32
870−0131 098−2235−02 098−7244
6 1 1
PART DESCRIPTION * * * * * * * * * *
Rectifier, Silicon (6 Amp) Pin, Contact Socket, Contact Connector, Receptacle (3 Pin) Wedge, Receptacle (3 Pin) Connector, Plug (2 Socket) Wedge, Plug (2 Socket) Plug (2 Pin) Pin, Contact Seal, Cable Relay − 24V Screw, Brass − Round Head − W/ET (#10−32 x 7/8) Nut, Hex − Brass (#10−32) Washer, Flat − Brass (#10) Nut, Hex − W/ET (#10−32) Screw, Machine − Round Head − Cross Recessed W/IT (#8−32 x 5/8”) Nut, Hex − W/ET (#10−32) Label, Ground Label, Danger
* − Parts Included in 338−4392 Wiring Harness
18
Heat Exchanger
53 56
38
37
53
66 74
23
67
63
79
56
9
37
54
64 71
53
53 38
41 53
72
53 42 38 37
43
8
43
24
20
50 20 75 22 34
50 80 5 50
35
40
67 40 75 67
20 11 12
81
52
13 14 15
81
14 15
18
51
52
52
61
20
29 28
30
52 51
19 10
31 32 33
60
16 3
1
17
77
14 15
13
29
45
76
7 46
73
35 30
34
29
82 48
19
50
50
21
49
12 13
21
25
40 50
50
37 39 24
26
27
58
70
4
64
58
44
69
20 50
36 57
57
63
6
50
67
40 55
65
59
50
50
38 2
62
68
78
47
Heat Exchanger REF NO.
PART NO.
QTY USED
1 2 3 4 5 6 7 8 9 10 11
130−3770 130−3769 130−3772 130−4570 503−2268 130−3592−01 130−3592−02 130−3773 130−3766 130−5011−02 800−0310−97
1 1 1 2 2 1 1 1 1 1 4
12
800−0160
13 14 15 16 17 18
526−0027 22 850−0079 22 862−0008 22 526−0399−28 4 850−0070 4 800−0310−79 4
19 20 21 22 23 24 25 26 27
130−4982 505−0382 505−0601 309−0665 130−3969 505−1547 505−1553 505−0667 503−2267
1 6 3 1 1 2 1 1 1
28 29 30 31 32 33
505−0607 505−0103 307−2711 526−0219 850−0060 800−0310−68
1 3 2 4 4 4
34
800−0310−81 16
35 36 37 38 39 40
862−0007 503−2114 505−0011 502−1162 505−0020 505−1549
12
16 1 7 7 1 4
PART DESCRIPTION
REF NO.
Base, Heat Exchanger Panel, Heat Exchanger − Top Exchanger, Heat Tube, Heat Exchanger Hose, Coolant (3.0” x 13.0” Lg.) Guard, Radiator Guard, Radiator Elbow, Heat Exchanger Tank, Expansion Bracket, Flange Mounting Screw, Cap − Hex Head (Grade 5) (.750−10 x 3.50) Screw, Cap − Hex Head (.750−10 x 3.25) Washer, Flat (3/4) Washer, Lock (3/4) Nut, Hex (.75−10) Washer, Flat (Hardened) (5/8) Washer, Lock − Split (5/8) Screw, Cap − Hex Head (Grade 5) (.625−11 x 1.75) Exchanger, Heat Nipple, Pipe (3 x 2.63) Flange, Pipe (3”) Valve, Thermostatic Tank, Expansion Tee, Pipe Elbow, Pipe Nipple, Pipe (3 x 6.50) Hose, Radiator (3.0” x 10.5” Lg.) Bushing, Reducer (3 x 2-1/2) Nipple, Pipe (2-1/2 x 2-1/2) Valve, Solenoid (24V) Washer, Flat (1/2) Washer, Lock − Split (1/2) Screw, Cap − Hex Head (Grade 5) (.50−13 x 2.00) Screw, Cap − Hex Head (Grade 5) (.625−11 x 2.25) Nut, Hex (.63−11) Hose, Radiator Elbow, Street − 90 (1/4) Fitting, Barbed Hose Bushing, Reducer (3/4 x 1/4) Adapter, Pipe (Male)
20
PART NO.
QTY USED
41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60
503−2112 1 503−2113 1 505−1429 2 503−1729 1 505−1441 2 505−0044 1 505−1442 1 155−0899 1 503−1762 2 503−1872−05 16 503−1726 2 503−1872−09 4 503−0685 10 503−2115 1 503−2116 1 130−0449 2 503−1872−01 2 503−1872−02 2 130−5039−02 1 800−0310−69 3
61 62 63 64
862−0016 3 502−1146 1 518−0548−08 8 821−5003−03 20
65 66 67 68 69 70
503−2123 503−2124 503−1728 503−2118 870−0550−07 821−0033
71
821−5004−02 10
72 73 74 75 76 77 78 79 80 81 82
870−0550−09 10 226−4115 2 504−0175 2 155−2514−02 3 504−0028 1 505−0019 1 505−0180 1 505−1090 2 505−2164 1 155−2503 2 155−2514 1
1 1 4 1 2 6
PART DESCRIPTION Hose, Heat Exchanger Hose, Heat Exchanger Nipple, Combination Hose, Radiator Bushing, Reducer (4 x 2-1/2) Elbow, Pipe Elbow − 90 − Flange Flange, Companion (2-1/2) Hose, Coolant (3 x 8.5) Clamp, Hose Hose, Radiator (5 x 6) Clamp, Hose Clamp, Hose Hose, Heat Exchanger (3/8 ID) Hose, Heat Exchanger (3/8 ID) Cap, Radiator Clamp, Hose Clamp, Hose Tube, Water Screw, Cap − Hex Head (Grade 5) (.50 x 2.25) Nut, Hex (.50−13) Elbow − 45 Clamp, Hose Screw, Hex Head (5/16−18 x .75) Hose, Heat Exchanger Hose, Heat Exchanger Hose, Heat Exchanger Hose, Heat Exchanger Nut, Flange Head (5/6”) Screw, Self-Locking − Hex Head (7/16−14 x .75) Screw, Hex Head (3/8−16 x .75) Nut, Hex Flange Head Lead Valve, Gate (2-1/2) Gasket, Flange Cock, Drain (3/8) Bushing, Reducer (1/2 x 3/8) Plug, Flush Type Grommet Nipple, Pipe (3 x 7.5) Gasket, Flange Gasket, Flange
Remote Radiator
3 6 8
9 15
7
10 13
16 6
11 1
12
2
4
6
6
6
6 5 17
14
21
Remote Radiator REF NO.
PART NO.
QTY USED
1 2 3 4
130−5025−02 130−5024−02 130−5022−02 130−5023−02
5 6
130−5021−02 821−5003−03 28
7 8
232−4001 232−3938
1 1
9
232−3939
1
PART DESCRIPTION
REF NO.
Bracket, Guard − Left Side Bracket, Guard − Right Side Guard, Top − Remote Radiator Guard, Front − Remote Radiator Guard, Belt − Bottom Screw, Hex Head (5/16−18 x 3/4”) Guard, Alternator Guard, Alternator − Remote Radiator Bracket, Guard Alternator
22
PART NO.
QTY USED
10 11 12
850−2020 526−2140 800−3017−52
2 4 4
13
800−2201
2
14 15 16
821−5004−03 526−0027 130−3660−01
2 2 2
17
333215900
1
PART DESCRIPTION Washer, Lock − Spring (M20) Washer, Flat (M12) Screw, Cap − Hex Head (M12 x 1.75 x 20mm) Screw, Cap − Hex Head (M20 x 2.5 x 35mm) Screw, Hex Head (3/8−16 x 1”) Washer, Flat (3/4”) Spacer −13/16” Thick (Replaces Idler Mounting Bracket) Connection, Water Inlet
Radiator 50C Ambient 53 16
16
19
29 36
56
31
18
31
48 49 50
27
54
17
37
31
31
19 24
30
11
1
25
16 31 40
48
16 32 22
32
33 39
32
30
14 34
21
26
33 14
23 32
15
9
41
10
22
20
2
45
35 52 44 45
32
5
28
55
42 47
32
22
36 38
43
46
46 7
12
3
8
51
4 46 6
23
13
Radiator 50C Ambient REF NO. 1
PART NO.
QTY USED
130−5692
1
2 3 4 5 6 7 8 9 10
130−4893−03 191−2331−02 130−5786−02 130−5784−02 130−5785−02 130−5787−02 130−5086−02 130−5286−02 130−5010−02
1 1 1 1 1 1 1 1 1
11
130−5016−02
1
12 13 14 15 16 17
130−4944 130−5210 503−2135 130−4943−02 503−2132 130−5722−02
1 1 2 1 4 1
18 19 20 21 22 23 24 25 26 27 28
130−5723−02 501−0744−03 130−5724−02 130−5725−02 503−2130 130−5727−02 130−5728−02 155−3372 130−4992−02 123−2142−02
1 2 2 2 8 2 4 4 1 1
130−5729−02 A030C918
1 1
A030C915
1
29
PART DESCRIPTION
REF NO.
Radiator (See Separate Page for Service Parts) Guard, Fan (Right Side) Bracket, Belt Guard Guard, Belt (Right Side) Guard, Belt (Top) Guard, Belt (Bottom) Guard, Belt (Left Side) Guard, Belt (Cover) Bracket, Radiator Bracket, Radiator Support (Left Side) Bracket, Radiator Support (Right Side) Spacer, Fan Fan, Engine Hose, Radiator Tube, Radiator Outlet Hose, Radiator (2.75 x 5.00) Tube, Radiator Inlet (Right Side) Tube, Radiator Inlet (Left Side) Hose, Coolant Tube, Radiator − Air Outlet Tube, Radiator − Air Inlet Hose, Hump Plate, Support Bracket, Tube Clamp, Muffler Bracket, Radiator Support Bracket, Mounting Stiffener, Radiator (Left Side) Non−IBC IBC Stiffener, Radiator (Right Side) IBC
24
PART NO.
QTY USED
30 31 32 33 34
503−1133 2 503−1872−04 8 503−1872−07 26 526−2140 8 800−2113 4
35 36 37
860−2010 526−2120 800−2087
4 4 2
38
800−2095
2
39
800−3017−56
4
40
821−6003−03 22
41 42 43
870−2055 526−0219 821−0030
44 45 46
862−0016 8 850−0060 14 821−5003−03 20
47
800−0092
48 49 50 51 52 53 54 55 56
526−0027 12 862−0008 10 850−0079 10 130−4893−04 1 870−0281 4 332−2420 2 130−5769 1 A030C920 1 A030C923 1
2 8 4
8
PART DESCRIPTION Clamp, Hose Clamp, Hose Clamp, Hose Washer, Flat (M12) Screw, Cap − Hex Head (M12 x 1.75 x 35) Nut, Hex (M12) Washer, Flat (M10) Screw, Cap − Hex Head (M10 x 1.5 x 30) Screw, Cap − Hex Head (M10 x 1.5 x 70) Screw, Cap − Hex Head (M12 x 1.75 x 40) Screw, Hex Head (M8 x 1.25 x 25) Nut, Hex (M8 x 1.25) Washer, Flat (1/2) Screw, Serrated − Hex Flange Head (3/16−16 x 1.0) Nut, Hex (.50) Washer, Lock − Split (1/2) Screw, Hex Head (5/16−18 x .75) Screw, Hex Head (1/2−13 x 1.5) Washer, Flat (3/4) Nut, Hex (.75) Washer, Lock − Split (3/4) Guard, Fan (Left Side) Nut, Serrated − Flange (3/8−16) Mount, Cable Tie Gauge, Sight Bracket, Support (IBC) Bracket, Support (IBC)
Radiator Service Parts
14
18
9
12
23
20
13
7
1 6 5
19
4 17 21
17
22 10
10
2 8
16
4 15 3 14 12 13
REF NO. 1 2 3 4 5 6 7 8 9 10 11 12 13
6
11
PART NO.
QTY USED
130−5692−01 130−5692−02 130−5692−03 130−5692−04 130−5692−05 130−5692−06 130−6555 130−5692−08 130−5692−09 130−5692−10 130−5692−11 130−5692−12 130−5692−13
1 2 1 2 2 2 1 1 1 2 1 2 2
5
PART DESCRIPTION
REF NO.
Tank, Top − JW Sidemember Tank, Bottom − JW Gasket, NBC Strap, Tank Strap, Tank Cap, Pressure Stoneguard, Mesh Tank, Top − C/A Sidemember Tank, Bottom − C/A Gasket, CNAF Strap, Tank
25
PART NO.
QTY USED
14 15 16 17 18
130−5692−14 130−5692−15 130−5692−16 130−5692−17 130−5692−18
2 8 1 2 1
19 20 21 22 23
130−5692−19 2 130−5692−21 2 130−5692−22 1 130−5692−23 1 130−5769 A/R
PART DESCRIPTION Strap, Tank Tie, Angle Cowl, Fan Support Fill Tube/Hose Assembly (Replacement Hose, 5” L X 1.75” (Qty 2)) Adapter, Duct Bracket, Lifting Core − C/A Core − J/W Gauge, Sight
This Page Intentionally Left Blank.
26
Enclosure Steel
41 42
2 1
4
13
5 37
6 74
3 43 44
10 11 32 72 53 61
56 48 81
39 46
12
19 21
20 22
9 7
30
26 67 29 38
8
81 86 33 78 79 77 47
23 52 58
85
28
80 75 81 76 27 18 83 14 65 82
81 88 90 91
54
16 87
9 51
57
15 70 71 73
24 36
49
17 12 66
81 89
27
63
90 25 35 50 64 55 62 34 59 45
60
40 69 31 68
Enclosure Steel REF NO.
PART NO.
QTY USED
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19
405−8071−02 405−8072−02 405−8766−02 405−8767−02 405−8494−02 405−8495−02 405−8073−02 405−8615−02 405−8083−02 405−8536−02 405−8537−02 405−8573−02 405−8538−02 405−8539−02 405−8084−02 405−8635−02 405−8636−02 405−8637−02 405−8074−02
2 2 1 1 1 2 2 7 2 1 1 4 2 2 1 1 1 1 1
20 21
405−8608−02 405−8075−02
1 1
22 23
405−8609−02 405−8076−02
1 1
24
405−8077−02
1
25 26 27 28 29 30
405−8078−02 2 406−1075 16 405−8079−02 4 405−8080−02 4 405−8081−02 4 405−8633−02 4
31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54
406−0972−03 8 405−9114−02 2 306−3467 16 306−4966 16 405−8727−01 4 405−8727−02 4 405−8554−02 1 405−8555−02 1 405−8556−02 2 406−1082 8 405−7883 2 405−7885−02 2 405−7882 1 405−7884−02 1 517−0350 1 406−0929 4 517−0133 16 405−8493 7 405−8640 4 4 405−8641 405−8642 3 405−8777 1 405−8643 2 405−8644 2
PART DESCRIPTION
* * * * * * *
REF NO.
Panel, Roof − Center Panel, Roof − Side Panel, Roof − Side Panel, Roof − Side Retainer, Seal − Roof Retainer, Seal − Roof Stiffener, Roof − Truss Stiffener, Roof − Truss Stiffener, Enclosure − Upper Stiffener, Enclosure − Upper Stiffener, Enclosure − Upper Stiffener, Enclosure − Splice Stiffener, Roof Stiffener, Roof Stiffener, Enclosure − Lower Stiffener, Enclosure − Lower Stiffener, Enclosure − Lower Stiffener, Enclosure − Lower Post, Enclosure − Outlet − Right Hand Post, Enclosure − Right Hand Post, Enclosure − Outlet − Left Hand Post, Enclosure − Left Hand Post, Enclosure − Inlet − Left Hand Post, Enclosure − Inlet − Right Hand Post, Enclosure − Center Hinge Door, Enclosure Door, Enclosure Panel, Enclosure − Header Drip, Edge − Enclosure (Not Shown) Latch Cover, Enclosure Rod, Guide Rod, Roller Seal, Door Seal, Door Panel, Duct − Horizontal Upper Panel, Duct − Horizontal Lower Panel, Duct − Vertical Door, Stop Gasket, Enclosure Cover, Enclosure Gasket, Enclosure Cover, Enclosure Plug, Hole Clip, Panel Plug, Hole Retainer, Insulation − Roof Retainer, Insulation − Door Retainer, Insulation − Door Retainer, Insulation − Post Retainer, Insulation − Post Retainer, Insulation − Post Retainer, Insulation − Center Post
PART NO.
QTY USED
55 56 57 58 59 60 61 62 63 64
405−8645 4 405−6000−16 7 405−6000−17 3 405−8778 1 405−6000−20 4 405−6000−18 2 405−6000−19 2 405−8646 4 405−8647 4 821−6007−02 218
65
821−6003−02 56
66 67
870−2065−03 20 821−6006−01 102
68 69
818−0231−02 72 815−0181 8
70 71
526−0249−01 40 800−2089 20
72 73 74
818−0231−06 4 860−2009 20 895−0414 −
75 76
526−0018 800−2044
77 78 79 80 81
406−1090 16 526−0113 16 406−1089−02 16 406−1091−02 8
* * * * * * * * *
16 16 ^ * *
82
800−6294 82 800−6294 8 821−6003−03 14
83
870−0114
4
84 85 86
853−2012 853−2006 870−2054
40 32 16
* *
856−0008 856−0008 405−9020 405−9021 337−2953 853−0005
28 20 4 4 8 40
* * * *
87 88 89 90 91
* − Insulated Gensets ^ − Non-Insulated Gensets
28
PART DESCRIPTION Retainer, Insulation − Header Insulation, Panel Insulation, Panel Insulation, Panel − Post Insulation, Panel Insulation, Panel Insulation, Panel Insulation, Panel − Door Insulation, Panel − Door Screw, Hex Head (M8 x 1.25 x 20) Screw, Hex Head (M8 x 1.25 x 20) Nut, Hex − Flange Screw, Hex Head (M6 x 1.0 x 16) Rivet, Pop Screw, Hex Head − Thread Cutting (#10−32 x 0.50) Washer, Flat (7/16) Screw, Hex Head (M10 x 1.5 x 40) Rivet, Pop Nut, Hex (M10 x 1.5) Tape, Weather Strip − Bulk (Order by the Foot − 147 Feet Required) Washer, Flat (1/4) Screw, Cap − Hex Head (M6 x 1 x 70) Spacer, Latch Washer, Flat (5/16) Bracket, Latch Bracket, Latch − Housing Screw, Hex − Flange Head − Thread Forming (#8 x 5/8”) Insulated Gensets Non-Insulated Gensets Screw, Cap − Hex Head (M8 x 1.25 x 25) Nut, Captive − Floating (5/16−18) Washer, Lock −W/ET (M12) Washer, Lock − W/ET (M6) Nut, Lock − Flange (M6 x 1) (Not Shown) Washer, Lock − W/EIT (5/16) Insulated Gensets Non-Insulated Gensets Bracket, Enclosure − Ground Bracket, Enclosure − Ground Strap, Bond Washer, Lock − W/ET (#8)
Enclosure Steel − F200−1
41 42
2 1
4
13
5 37
6 74
3 43 44
10 11 32 72 53 61
56 48 81
39 46
12
19 21
20 22
9 7
30
26 67 29 38
8
81 86 33 78 79 77 47
23 52 58
85
28
80 75 81 76 27 18 83 14 65 82
81 88 90 91
54
16 87
9 51
57
15 70 71 73
24 36
49
17 12 66
81 89
29
63
90 25 35 50 64 55 62 34 59 45
60
40 69 31 68
Enclosure Steel − F200−1 REF NO.
PART NO.
QTY USED
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19
405−8071−02 405−8072−02 405−8766−02 405−8767−02 405−8494−02 405−8495−02 A030Y075 405−8615−02 405−8083−02 405−8536−02 405−8537−02 A030Y120 405−8538−02 405−8539−02 A030Y116 A030Y103 A030Y108 A030Y112 A029Z466
2 2 1 1 1 2 2 7 2 1 1 4 2 2 1 1 1 1 1
20 21
A030Y079 A029Z470
1 1
22 23
A040Y083 A030Y087
1 1
24
A030Y093
1
25 26 27 28 29 30
A030Y097 2 406−1075 16 405−8079−02 4 405−8080−02 4 405−8081−02 4 405−8633−02 4
31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54
406−0972−03 8 405−9114−02 2 306−3467 16 306−4966 16 405−8727−01 4 405−8727−02 4 A030Y031 1 A030Y035 1 A030Y039 2 A034B444 8 405−7883 2 405−7885−02 2 405−7882 1 405−7884−02 1 517−0350 1 406−0929 4 517−0133 16 405−8493 7 405−8640 4 405−8641 4 405−8642 3 405−8777 1 405−8643 2 405−8644 2
PART DESCRIPTION
* * * * * * *
REF NO.
Panel, Roof − Center Panel, Roof − Side Panel, Roof − Side Panel, Roof − Side Retainer, Seal − Roof Retainer, Seal − Roof Stiffener, Roof − Truss Stiffener, Roof − Truss Stiffener, Enclosure − Upper Stiffener, Enclosure − Upper Stiffener, Enclosure − Upper Stiffener, Enclosure − Splice Stiffener, Roof Stiffener, Roof Stiffener, Enclosure − Lower Stiffener, Enclosure − Lower Stiffener, Enclosure − Lower Stiffener, Enclosure − Lower Post, Enclosure − Outlet − Right Hand Post, Enclosure − Right Hand Post, Enclosure − Outlet − Left Hand Post, Enclosure − Left Hand Post, Enclosure − Inlet − Left Hand Post, Enclosure − Inlet − Right Hand Post, Enclosure − Center Hinge Door, Enclosure Door, Enclosure Panel, Enclosure − Header Drip, Edge − Enclosure (Not Shown) Latch Cover, Enclosure Rod, Guide Rod, Roller Seal, Door Seal, Door Panel, Duct − Horizontal Upper Panel, Duct − Horizontal Lower Panel, Duct − Vertical Door, Stop Gasket, Enclosure Cover, Enclosure Gasket, Enclosure Cover, Enclosure Plug, Hole Clip, Panel Plug, Hole Retainer, Insulation − Roof Retainer, Insulation − Door Retainer, Insulation − Door Retainer, Insulation − Post Retainer, Insulation − Post Retainer, Insulation − Post Retainer, Insulation − Center Post
PART NO.
QTY USED
55 56 57 58 59 60 61 62 63 64
405−8645 4 405−6000−16 7 405−6000−17 3 405−8778 1 405−6000−20 4 405−6000−18 2 405−6000−19 2 405−8646 4 405−8647 4 821−6007−02 218
65
821−6003−02 56
66 67
870−2065−03 20 821−6006−01 102
68 69
818−0231−02 72 815−0181 8
70 71
526−0249−01 40 800−2089 20
72 73 74
818−0231−06 4 860−2009 20 895−0414 −
75 76
526−0018 800−2044
77 78 79 80 81
406−1090 16 526−0113 16 406−1089−02 16 406−1091−02 8
* * * * * * * * *
16 16 ^ * *
82
800−6294 82 800−6294 8 821−6003−03 14
83
870−0114
4
84 85 86
853−2012 853−2006 870−2054
40 32 16
* *
856−0008 856−0008 405−9020 405−9021 337−2953 853−0005
28 20 4 4 8 40
* * * *
87 88 89 90 91
* − Insulated Gensets ^ − Non-Insulated Gensets
30
PART DESCRIPTION Retainer, Insulation − Header Insulation, Panel Insulation, Panel Insulation, Panel − Post Insulation, Panel Insulation, Panel Insulation, Panel Insulation, Panel − Door Insulation, Panel − Door Screw, Hex Head (M8 x 1.25 x 20) Screw, Hex Head (M8 x 1.25 x 20) Nut, Hex − Flange Screw, Hex Head (M6 x 1.0 x 16) Rivet, Pop Screw, Hex Head − Thread Cutting (#10−32 x 0.50) Washer, Flat (7/16) Screw, Hex Head (M10 x 1.5 x 40) Rivet, Pop Nut, Hex (M10 x 1.5) Tape, Weather Strip − Bulk (Order by the Foot − 147 Feet Required) Washer, Flat (1/4) Screw, Cap − Hex Head (M6 x 1 x 70) Spacer, Latch Washer, Flat (5/16) Bracket, Latch Bracket, Latch − Housing Screw, Hex − Flange Head − Thread Forming (#8 x 5/8”) Insulated Gensets Non-Insulated Gensets Screw, Cap − Hex Head (M8 x 1.25 x 25) Nut, Captive − Floating (5/16−18) Washer, Lock −W/ET (M12) Washer, Lock − W/ET (M6) Nut, Lock − Flange (M6 x 1) (Not Shown) Washer, Lock − W/EIT (5/16) Insulated Gensets Non-Insulated Gensets Bracket, Enclosure − Ground Bracket, Enclosure − Ground Strap, Bond Washer, Lock − W/ET (#8)
Enclosure Aluminum
2
3
41 89
1
37
13
5 6 4 90 43 44 10 11 85
56
53 61 39 46 12
48
19 21 9 7
20 83 22 81,92 30 67 26 29 38
84
8
33 77 47 76
23 52 58
28
75
73 78 74 79 40 18 82
27 31 68
9 14 68
80 86
88 80 87 51
54 35 25
57 24
63
36 16 69 70 71 72
49
15
31
17 12 66 64
34 59
55
50 62
60 45
Enclosure Aluminum REF NO.
PART NO.
QTY USED
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19
405−8836 405−8837 405−8839 405−8838 405−8878 405−8879 405−8893 405−8615−02 405−8881 405−8880 405−8892 405−8573−02 405−8538−02 405−8539−02 405−8913 405−8910 405−8911 405−8912 405−8898
2 2 1 1 1 2 2 7 2 1 1 4 2 2 1 1 1 1 1
20 21
405−8897 405−8900
1 1
22 23
405−8609−02 405−8899
1 1
24
405−8894
1
25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51
405−8896 406−1075 405−8812 405−8811 405−8895 405−9179 406−0972−03 517−0138−08 306−3467 306−4966 405−8727−01 405−8727−02 405−8914 405−8915 405−8916 406−1082 405−7883 405−7885−02 405−7882 405−7884−02 517−0350 406−0929 517−0133 405−8493 405−8640 405−8641 405−8642
2 16 4 4 4 4 8 2 16 16 4 4 1 1 2 8 2 1 1 1 1 8 16 7 4 4 3
PART DESCRIPTION
* * * *
REF NO.
Panel, Roof − Center Panel, Roof − Side Panel, Roof − Side Panel, Roof − Side Retainer, Seal − Roof Retainer, Seal − Roof Stiffener, Roof − Truss Stiffener, Roof − Truss Stiffener, Enclosure − Upper Stiffener, Enclosure − Upper Stiffener, Enclosure − Upper Stiffener, Enclosure − Splice Stiffener, Roof Stiffener, Roof Stiffener, Enclosure − Lower Stiffener, Enclosure − Lower Stiffener, Enclosure − Lower Stiffener, Enclosure − Lower Post, Enclosure − Outlet − Right Hand Post, Enclosure − Right Hand Post, Enclosure − Outlet − Left Hand Post, Enclosure − Left Hand Post, Enclosure − Inlet − Left Hand Post, Enclosure − Inlet − Right Hand Post, Enclosure − Center Hinge Door, Enclosure Door, Enclosure Panel, Enclosure − Header Drip, Edge − Enclosure Latch Plug, Hole (Not Shown) Rod, Guide Rod, Roller Seal, Door Seal, Door Panel, Duct − Horizontal Upper Panel, Duct − Horizontal Lower Panel, Duct − Vertical Door, Stop Gasket, Enclosure Cover, Enclosure (Not Shown) Gasket, Enclosure Cover, Enclosure Plug, Hole Clip, Panel Plug, Hole Retainer, Insulation − Roof Retainer, Insulation − Door Retainer, Insulation − Door Retainer, Insulation − Post
PART NO.
QTY USED
PART DESCRIPTION
1 2 2
* Retainer, Insulation − Post * Retainer, Insulation − Post * Retainer, Insulation − Center Post * Retainer, Insulation − Header * Insulation, Panel * Insulation, Panel * Insulation, Panel − Post * Insulation, Panel * Insulation, Panel * Insulation, Panel * Insulation, Panel − Door * Insulation, Panel − Door Screw, Hex Head (M8 x 1.25 x 20) Screw, Hex Head (M8 x 1.25 x 20) Nut, Hex − Flange Screw, Hex Head (M6 x 1.0 x 16) Rivet, Pop Washer, Flat (7/16) Screw, Cap − Hex Head (M10 x 1.5 x 40) Washer, Lock − Split (M10) Nut, Hex (M10 x 1.5) Washer, Flat (1/4) Screw, Cap − Hex Head (M6 x 1 x 70) Spacer, Latch − Rod Guide ^ Washer, Flat (5/16) * Bracket, Latch * Bracket, Latch − Housing Screw, Hex − Flange Head − Thread Forming (#8 x 5/8”) Insulated Gensets Non-Insulated Gensets Screw, Hex Head (M8 x 1.25 x 25) Nut, Captive − Floating Washer, Lock − W/ET (M12) * Washer, Lock − W/ET (M6) * Bracket, Enclosure − Ground * Cover, Enclosure * Bracket, Enclosure − Ground Strap, Bond * Washer, Lock − W/ET (#8) Cover, Enclosure Tape, Weather Strip − Bulk (Order by the Foot − 13 Feet Required) * Nut, Locking − Flange (M6 x 1)
52 53 54
405−8777 405−8643 405−8644
55 56 57 58 59 60 61 62 63 64
405−8645 4 405−6000−16 7 405−6000−17 3 405−8778 1 405−6000−20 4 405−6000−18 2 405−6000−19 2 405−8646 4 405−8647 4 821−6007−02 251
65
821−6003−02 56
66 67
870−2065−03 20 821−6006−01 102
68 69 70
818−0231−02 80 526−0249−01 44 800−2089 20
71 72 73 74
850−2010 860−2009 526−0018 800−2044
75 76 77 78 79
406−1090 16 526−0113 16 406−1089−02 16 406−1091−02 8
20 20 16 16
80
71 800−6294 800−6294 8 821−6003−03 14
81 82 83 84 85 86 87 88 89 90
870−0504 853−2012 853−2006 405−9020 405−9145 405−9021 337−2953 853−0005 405−8737 895−0414
4 40 32 4 4 4 8 40 1 −
91
870−2054
16
* − Insulated Gensets ^ − Non-Insulated Gensets
32
Skid
2 4 5
3 2
1
4 6
REF NO. 1 2 3
PART NO. 403−3846 403−4211 526−0027 800−0161
QTY USED 1 1 12 2
5
PART DESCRIPTION Skid HC6 Generator P7 Generator Washer, Flat (3/4”) Screw, Cap − Hex Head (3/4−10 x 3-1/2”)
33
REF NO.
PART NO.
QTY USED
4 5 6
850−0079 862−0008
6 6
501−0522 501−0520
1 1
PART DESCRIPTION Washer, Lock − Spring (3/4”) Nut, Hex (3/4−10) Line, Flexible − Fuel Fuel In Fuel Out
Skid−IBC
7
6 2
3 2
4 5 1
4 5
REF NO.
PART NO.
QTY USED
1 2 3
A030B765 526−0027 A030G800
12 2
4 5
850−0079 862−0008
6 6
PART DESCRIPTION Skid Washer, Flat (3/4”) Screw, Cap − Hex Head (3/4−10 x 3-1/2”) Washer, Lock − Spring (3/4”) Nut, Hex (3/4−10)
REF NO.
PART NO.
QTY USED
PART DESCRIPTION
6
A030G790
4
501−0522 501−0520
1 1
Screw, Cap − Hex Head (3/4−10 x 3”) Line, Flexible − Fuel Fuel In Fuel Out
7
34
Skid−IBC
7
6 2
3 2
4 5 1
4 5
REF NO.
PART NO.
QTY USED
1 2 3
A030B763 526−0027 A030G800
12 2
4 5
850−0079 862−0008
6 6
PART DESCRIPTION Skid Washer, Flat (3/4”) Screw, Cap − Hex Head (3/4−10 x 3-1/2”) Washer, Lock − Spring (3/4”) Nut, Hex (3/4−10)
REF NO.
PART NO.
QTY USED
PART DESCRIPTION
6
A030G790
4
501−0522 501−0520
1 1
Screw, Cap − Hex Head (3/4−10 x 3”) Line, Flexible − Fuel Fuel In Fuel Out
7
35
Entrance Box
11
10
13
4 3
2 1 7
6
8 9 12 5
REF NO.
PART NO.
QTY USED
1 2 3
319−5161−02 319−5084−02 319−5171−02
1 1 1
4
319−5162−02
1
5 6 7
319−5088−02 1 821−6003−02 69 319−5179−02 1
PART DESCRIPTION
REF NO.
Box, Circuit Breaker Panel, Terminal Cover, Circuit Breaker − Bottom Entrance Cover, Circuit Breaker − Top and Bottom Entrance Cover, Circuit Breaker Screw, Hex (M8 x 1.25 x 20) Bracket, Circuit Breaker
36
PART NO.
QTY USED
8 9 10 11
319−5102−04 821−6002−03 098−6635 319−5163−02
1 8 1 1
12 13
319−5176−06
1
098−5347 098−5347−02
1 1
PART DESCRIPTION Stiffener, Cover Screw, Hex (M6 x 1 x 16) Label, Ground Cover, Circuit Breaker − Top − Top and Bottom Entrance Cover, Circuit Breaker − Front Label, Danger English French
Control Housing Model HC6 Generator
5
6
1 4 8 11
9
11 2
10 12
4 3
7
REF NO.
PART NO.
QTY USED
1 2
319−5504−02 319−5505−02
1 1
3
319−5506−02
1
4 5 6
319−5097−02 2 319−5083−02 1 821−6003−02 52
PART DESCRIPTION
REF NO.
Panel, Control Housing − Back Panel, Control Housing − Left Side Panel, Control Housing − Right Side Panel, Control Housing Panel, Control Housing − Top Screw, Hex Head (M8 x 1.25 x 20)
7 8 9 10 11 12
37
PART NO.
QTY USED
821−6004−01 10 508−1090 319−5725−02 319−5188−02 319−5721−02 856−0010
1 1 2 2 2
PART DESCRIPTION Screw, Hex Head (M10 x 1.5 x 20) Grommet Panel, Control Housing − Front Bracket, Terminal Box Bracket, Terminal Box Washer, Lock − W/EIT
Control Housing Model P7 Generator
6 5
13 12 11 7
1 4
7
8
6 2 3 9 10 REF NO. 1 2 3 4 5 6
PART NO.
QTY USED
319−5184−02 1 319−5081−02 1 319−5082−02 1 319−5085−02 1 319−5083−02 1 821−6003−02 60
PART DESCRIPTION
REF NO.
Panel, Terminal − Front Panel, Terminal − Back Panel, Terminal − Left Panel, Terminal − Right Panel, Terminal − Top Screw, Hex Head (M8 x 1.25 x 20)
7 8 9 10 11 12 13
38
PART NO.
QTY USED
319−5097−02 2 319−5488−02 4 800−2061 12 526−0399−60 12 319−5188−02 2 508−1090 1 518−0548−24 2
PART DESCRIPTION Panel, Terminal Box, Terminal − Spacer Screw, Hex Head (M8 x 40) Washer, Flat (M8) Bracket, Terminal Box Grommet Clamp, Hose
Generator Mounting Model HC6 Generator
11
12 4
10
9 1
14 13
5 6 7 8
2 3
REF NO. 1 2 3 4 5 6 7 8 9
PART NO.
QTY USED
526−0027 4 850−0079 4 862−0008 4 526−0416 6 232−3941−01 A/R 232−3941−02 A/R 232−3941−03 A/R 232−3941−04 4 800−0163 4
PART DESCRIPTION
REF NO.
Washer, Flat (3/4”) Washer, Lock − Spring (3/4”) Nut, Hex (3/4−10) Washer, Flat (5/8”) Shim − 2.6mm Thick Shim − 1.9mm Thick Shim − .6mm Thick Shim − 4.8mm Thick Screw, Cap − Hex Head (3/4−10 x 4”)
10 11
850−2012 16 800−2543−05 16
12
805−0035
6
13 14
327−0923 526−0018
2 2
39
PART NO.
QTY USED
PART DESCRIPTION Washer, Lock − Spring (M12) Screw, Cap − Hex Head (M12 x 40mm − Grade 10.9) Bolt, Place (5/8−11 x 1−1/2” − Grade 8) Clamp, J Washer, Flat (1/4”)
Generator Mounting Model P7 Generator
4
6
5 7
1 11 10
15
2 8 9 12
14 13 11 3
REF NO.
PART NO.
QTY USED
1
800−0161
4
2 3 4
232−3941−01 4 862−0008 4 800−2543−06 16
5 6
850−2012 805−0035
16 6
7
526−0416
6
PART DESCRIPTION
REF NO.
Screw, Cap − Hex Head (3/4−10 x 3.5”) Shim − 2.6mm Thick Nut, Hex (3/4−10) Screw, Cap − Hex Head (M12 x 1.75 x 45) Washer, Lock (M12) Bolt, Place (5/8−11 x 1−1/2”) (Grade 8) Washer, Flat (5/8”)
8 9 10 11 12 13 14 15
40
PART NO.
QTY USED
232−3941−02 232−3941−03 332−3196 526−0027 232−3941−04 850−0079 403−4239 526−0444
4 4 1 4 4 4 4 4
PART DESCRIPTION Shim − 1.9mm Thick Shim − .6mm Thick Clamp, J Washer, Flat (3/4”) Shim − 4.8mm Thick Washer, Lock (3/4”) Spacer Washer, Flat (Generator Mounting)
Generator Heater 5 15
6
12
4 2 11
17
10
13
9 7
8
16
14 1
3
9
REF NO. 1
PART NO.
QTY USED
2 3 4
333−0438−05 333−0438−06 232−3849 332−3024−14 822−3075
1 1 1 2 6
5 6 7 8 9
850−2004 860−2005 850−2005 860−2006 800−2008
2 2 2 2 2
PART DESCRIPTION Cartridge, Heater (300 Watt) 120 Volt 240 Volt Bracket, Mounting − Heater Clamp, Loop Screw, Machine − Slotted Pan Head (M4 x 16mm) Washer, Lock − Spring (M4) Nut, Hex (M4) Washer, Lock − Spring (M5) Nut, Hex (M5) Screw, Cap − Hex Head (M5 x 16mm)
41
REF NO.
PART NO.
QTY USED
10 11
850−2003 822−3047
1 1
12 13 14 15 16 17
508−0228 332−3023 898−1254−25 330−0142 517−0021 330−0141−01
1 1 1 1 1 1 1 1
PART DESCRIPTION Washer, Lock − Spring (M3) Screw, Machine − Pan Head (M3 x 20mm) Grommet Block, Terminal Sleeving − Heater Leads (59”) Box, Terminal Plug, Dot Button Cover Assy Cover, Box Gasket, Cover
Generator
For COMPLETE generator replacement use the 200−XXXX−XX Cummins Power Generation identification number. Generator component parts cannot be ordered from Cummins Power Generation. Refer to the Newage nameplate and supply all available information. Contact your nearest Newage distributor for assistance in ordering component parts. For COMPLETE generator replacement use the 200−XXXX−XX Cummins Power Generation identification number listed below.
Cummins Power Generation Identification Number
Generator Model
200−3051−01
HC634G
200−3051−02
HC634H
200−3051−03
HC634J
200−3051−07
HC634K
200−3052−01
HC634G
200−3052−02
HC634H
200−3052−03
HC634J
200−3052−07
HC634K
200−3053−01
HC634G
200−3053−02
HC634H
200−3053−03
HC634J
200−3053−07
HC634K
200−3128−01
P7B
200−3128−02
P7C
200−3128−19
P7B
42
Control Box Mounting
7 6
8 5 13
10
16 9 11
12 13
13 15 5
8 7
4 9 13 2
1
3 2 14
43
6
Control Box Mounting REF NO.
PART NO.
QTY USED
1 2 3 4 5 6 7
319−5558−02 319−5520−02 821−6002−03 319−5631−02 402−0666−01 526−0324 815−0776
1 2 8 1 4 4 4
8 9
818−0231−02 503−1418
8 2
PART DESCRIPTION
REF NO.
Base, Control Box Channel, Support Screw, Hex Head (M6 x 1 x 16) Bracket, Control Isolator, Vibration Washer, Flat (3/8) Screw, Hex Head − Flange (M8 x 1.25 x 45) Rivet, Pop Hose, Fuel
44
PART NO.
QTY USED
10 11 12 13
319−5052−02 1 098−8186 1 319−5632−02 1 821−6003−02 16
14
821−6004−01
4
15 16
853−2008 337−0049
4 1
PART DESCRIPTION Bracket, Control Label, Caution Bracket, Control Screw, Hex Head (M8 x 1.25 x 20) Screw, Hex Head (M10 x 1.5 x 20) Washer, Lock − W/ET (M8) Strap, Bond
Control Box Installation
4
2
8
1
7
5 6 3
9
5
7
1
2
4
REF NO.
PART NO.
QTY USED
1 2 3 4
402−0666−01 526−0324 818−0231−02 815−0776
4 4 8 4
5
853−2008
4
PART DESCRIPTION
REF NO.
Isolator, Vibration Washer, Flat (3/8) Rivet, Pop Screw, Hex Head − Flange − Thread Forming (M8 x 1.25 x 45) Washer, Lock − W/ET (M8)
45
PART NO.
QTY USED
6
821−6003−02
2
7
503−1418
−
8 9
098−8186 337−0049
1 1
PART DESCRIPTION Screw, Hex Head (M8 x 1.25 x 20) Hose, Fuel − Bulk (Order by the Foot − 4 Feet Required) Label, Caution Strap, Bond
Control Heater
3 6
4
2
5 1
REF NO.
PART NO.
QTY USED
1
2
333−0645−01 333−0645−02 818−1150−02
1 1 2
PART DESCRIPTION
REF NO.
Heater Assembly, Control − 150 Watt 120 Volt 240 Volt Rivet, Drive
3 4 5 6
46
PART NO. 332−3125−01 332−3126−01 098−6195 332−4002
QTY USED 2 1 2 1
PART DESCRIPTION Block, Terminal Endplate, Terminal Label, Caution Block, Terminal − Ground
Control Door
22 23 26 1
24
16
17 18
15 11
13
6
33
3
2
9 37
12
4
32 27
5
28
6
31 30
20 21
8 30 10
35 25 29
34 7
47
36
Control Door REF NO.
PART NO.
QTY USED
1 2 3
319−5018−02 1 332−1911 15 300−5180 1
4
300−5179
5 6
326−0230 1 823−0001−01 12
7 8 9 10 11 12
PART DESCRIPTION
1
526−2303 860−2006 870−2064−01 870−2062 300−5685−01 300−5181
1 3 9 3
338−4649−01
1
338−4649−02
1
14
323−1839
1
*#
15
308−1085
1
*
16 17
308−0999 323−1688
1 6
*# *#
13
1
REF NO.
Door, Control Box Spacer, LED Board, Printed Circuit − Bargraph Board, Printed Circuit − Operator Panel − Digital Display, Digital Screw, Pan Head − Thread Forming (M3 x 0.5 x 6) Washer, Double Hole Nut, Hex (M5 x .8) Nut, Nyloc (M4) Nut, Nylon − Lock (M5) Display, Control Board, Printed Circuit − Software Panel Harness, Switch Panel CAN Switch Panel With Knob (Includes Parts Marked *) CAN Switch Panel Without Knob (Includes Parts Marked #) Connector − 6 Pin (Not Illustrated) Switch, Selector − Switch Panel With Knob Switch, Emergency Stop Socket, Terminal
PART NO.
QTY USED
18 19
332−3491−01 308−1085−01
6 1
20 21 22 23 24 25 26 27 28
300−4306 872−0019−01 322−0361 322−0017 406−0930 406−0932−02 322−0488 319−4918−02 815−0796
1 2 1 1 1 1 4 1 4
29 30 31 32 33
425−1799 870−2062 332−0052 406−0810 821−6001−01
2 4 1 2 4
34 35 36 37
508−1186 405−7779 319−5194 319−5193
2 1 1 1
PART DESCRIPTION *# Terminal, Wire Pin # Switch, Selector − Switch Panel With Key (Not Illustrated) Regulator, Auto Voltage Standoff Light, Panel Lamp, Panel Latch, Door (1/4 Turn) Latch, Cam (Single Point) Lens, LED Bracket, Printed Circuit Board Screw, Pan Head − Thread Cutting (4−24 x 5/16) Clamp, Cable Nut, Nylon − Lock (M5) Clip, Wire Hinge, Block Screw, Hex Head (M5 x 0.8 x 10) Bumper Gasket, Enclosure Cover, Printed Circuit Board Bracket, Control
* − Included in 338−4649−01 Wiring Harness # − Included in 338−4649−02 Wiring Harness
48
Control Box
18
17
20 15
12
14
10
20 14
12
6 13 6
1
4 5
11 7 16 3 9
19
8
2
REF NO.
PART NO.
QTY USED
PART DESCRIPTION
REF NO.
PART NO.
QTY USED
1 2 3 4 5
319−5014−02 098−8121 818−1150−02 332−2879−09 815−0793−02
1 1 2 1 2
11 12 13 14 15
870−2062 853−2008 337−0049 870−2055 821−2045
2 2 1 2 1
6
823−0002−05 24
Box, Control Label, Information Rivet, Drive Rail, Terminal Screw, Flange Head (M5 x 0.8 x 10) Screw, Pan Head − Torx − Thread Forming (M4 x 0.7 x 14) Block, Terminal Harness, Lonworks Label, Ground Plug, Hole
16 17 18
526−0008 319−5135−02 819−1157
2 1 2
19 20
338−4302 526−0115
1 2
7 8 9 10
332−2878 338−4315 098−6635 517−0133
2 1 1 8
49
PART DESCRIPTION Nut, Nylon − Lock (M5) Washer, Lock − W/ET (M8) Strap, Ground Nut, Lock − Flange (M8) Screw, Locking − Flange (M8 x 1.25 x 16) Washer, Flat (M5) Bracket, Cable Screw, Pan Head − Cross Recessed (M6 x 1 x 50) Harness, Engine Washer, Flat
Card Cage 8
3 9 10 12 13 11
5
4
6
1
7 2
8
REF NO.
PART NO.
QTY USED
PART DESCRIPTION
REF NO.
1 2 3 4
319−5096−02 363−0183 541−0809 327−1390
1 1 1 1
9 10
5 6
815−0948
8
406−0916 406−0917 815−0949 815−0947
4 4 16 8
Frame, Cabinet Heatsink, Genset Board, Printed Circuit − NCM Board, Printed Circuit − Backplane Screw, Torq (M4 x 6) Guide, Metal Guide Left Side Right Side Screw (4−40 x 1/4) Screw (M3 x 10)
7 8
50
PART NO. 319−5079
QTY USED A/R
11 12
327−1376−01 1 327−1376−02 1 323−1848 A/R 327−1392 1
13
300−5326
1
PART DESCRIPTION Cover, Control − Blank Board, Printed Circuit − Parallel Genset Full Feature (Marked #1) Depop Feature (Marked #2) Cover, 96-Pin Header Board, Printed Circuit − Genset Base Board, Printed Circuit − Fuel Card (RE30 Genset)
Current Transformer
7
6
2
1
5 3
4
REF NO.
PART NO.
QTY USED
1 302−2057−36 302−2057−37 302−2057−38 302−2057−39 302−2057−41 302−2057−42 302−2057−49
3 3 3 3 3 3 3
PART DESCRIPTION
REF NO.
Transformer, Current (CT21, CT22, CT23) Ratio 2141/1 or 4282/1 Ratio 2279/1 or 4558/1 Ratio 2366/1 or 4732/1 Ratio 2523/1 or 5046/1 Ratio 2839/1 or 5678/1 Ratio 3154/1 or 6308/1 Ratio 1893/1 or 3786/1
51
PART NO.
QTY USED
2
338−3019
1
3 4 5
323−1644−03 1 323−1648 10 856−0008 2
6 7
319−5740−03 821−6002−02
1 8
PART DESCRIPTION Harness, Wiring (Includes Plug and Sockets) (P9 To CT21,22,23 and 5,6,7,8) (60”) Plug − 12 Place (P9) Socket, Contact Washer, Lock − W/EIT (5/16”) (Grounding Wires) Base, Transformer Screw, Hex Head (M6)
PT/CT Module
2 3 4
REF NO.
PART NO.
2
QTY USED
PART DESCRIPTION
REF NO.
1 1 1
Board, Printed Circuit − PT/CT Module 120 Volts 240 Volts 346 Volts
2 3 4
1 300−4308−01 300−4308−02 300−4308−03
1
52
PART NO.
QTY USED
870−2062 872−0019−01 332−0052
2 1 1
PART DESCRIPTION Nut, Nylon − Lock (M5) Standoff Clip, Wire
Customer Relays
2 1
REF NO. 1
PART NO. 307−1056 307−1056
QTY USED 1 3
PART DESCRIPTION
REF NO.
Relay (24 Volt) Alarm Relay (K16) Run Relay (K11,12,13)
2
53
PART NO.
QTY USED
323−1410−01 323−1410−01
1 3
PART DESCRIPTION Socket, Relay Alarm Relay Run Relay
Pyrometer
11 7 5 8 9
3 10
4
6
2
1
REF NO.
PART NO.
QTY USED
PART DESCRIPTION
REF NO.
PART NO.
1 2 3
098−7720−01 300−5796 338−4340−01
2 2 1
4
338−4340−02
1
5
193−0493−01
2
Label, Exhaust − Pyrometer Pyrometer, Exhaust Harness, Meter − Pyrometer (Labeled) Harness, Meter − Pyrometer (Labeled) Sender, Temperature
6 7 8 9 10 11
098−8157 518−0350 821−6003−01 505−2138 098−8184 155−2531−04
54
QTY USED 3 9 9 2 1 1
PART DESCRIPTION Label, Instruction Clamp Screw Adapter, Pipe (1/8 x M16) Label, Instruction − Switch Elbow, Exhaust − Outlet
Bus PT Module
2
1
4
2 3
REF NO.
PART NO.
QTY USED
1 300−4985−01 300−4985−02 300−4985−03 300−4985−04
1 1 1 1
PART DESCRIPTION
REF NO.
Board, Printed Circuit − Bus PT Module 120 Volts 240 Volts 346 Volts 60 Volts
55
2 3 4
PART NO.
QTY USED
870−2062 872−0019−01 319−5060
3 2 1
PART DESCRIPTION Nut, Nylon − Lock (M5) Standoff Guard, Electrical
Audible Alarm Module
2 7 10 9 1 6
8 5
REF NO.
PART NO.
QTY USED
1 2
098−7719−01 338−4351
1 1
3 4 5
323−1899−01 322−0491 322−0493−05
3 3 1
PART DESCRIPTION Label, Alarm Harness, Alarm (Includes the Following Parts) Connecter, LED Lamp, LED − High Intensity Lens, LED (Amber)
56
REF NO.
PART NO.
QTY USED
6 7 8 9 10
322−0493−04 322−0493−06 308−1105 333−0654 895−0401
1 1 1 1 1
3 4
PART DESCRIPTION Lens, LED (Green) Lens, LED (Red) Switch, Toggle Alarm, Audible Gasket, Audible Alarm
Ground Fault Relay
11
13 8
1
12 6 10
7
18
9 5
2
20
4
16
20 16 18 19
16
16
5
3 6 17
15
14
REF NO.
PART NO.
QTY USED
1 2 3 4 5 6 7 8 9 10
307−3003−01 821−0017 870−0257 402−0354 853−0005 870−0221 338−4408 332−2420 319−5038−02 315−1605−01
1 2 2 4 8 8 1 2 1 1
11
821−0010
2
PART DESCRIPTION
REF NO.
Relay, Ground Fault Screw, Locking (5/16−18 x 1/2) Nut, Self-Locking (5/16−18) Mount, Shock Washer, Lock − W/ET (#8) Nut, Hex − W/ET (#8−32) Harness, Relay Mount, Cable Tie Plate, Mounting − Relay Transformer, Current (Used With 4 Pole Separately Derived Transfer Switch) Screw, Locking (1/4−20 x 1/2)
PART NO.
QTY USED
PART DESCRIPTION
12 13 14 15 16 17
870−0212 338−4386 315−1622 315−1621 526−0003 812−0094
2 1 1 1 8 2
* * * *
18 19
850−0025 812−0082
4 2
* *
20
860−0008
4
*
Nut, Self-Locking (1/4−20) Harness, Meter − Resistor Bracket, Transformer − Current Transformer, Current Washer, Flat (3/16) Screw, Slotted − Round Head (#8−32 x 3.50) Washer, Lock − Split (#8) Screw, Slotted − Round Head (#8−32 x .75) Nut, Hex (#8−32)
* Used With 3 Pole Non-Separately Derived Transfer Switch
57
This Page Intentionally Left Blank.
58
Circuit Breaker NSJ 600 Amp
32
15
11
31 50
11 12
17
39
12
16
4
41
14
17
16
13
42
28 29
18 21
2
27
20
13
47
12
19 40 9
16
22 43
48
25 11
26 1 8
45
46 17
16 7
6
23
44
24
49
6 6 5
30 36 34
37
3
38 35
33
59
Circuit Breaker NSJ 600 Amp REF NO.
PART NO.
QTY USED
1
320−1960−01
2 3 4 5 6
319−5161−02 1 319−5084−02 1 319−5171−02 1 319−5088−02 1 821−6003−02 54
7
1
8 9 10
319−5176−04 319−5176−05 319−5078−06 319−5179−02 098−8144
1 1 1 1 1
11 12 13
332−2512 850−0050 800−0048
8 8 8
14 15 16 17
337−3632 1 526−0423 2 851−0048−02 10 6 800−0050
18 19
332−3039 800−0028
3 1
20 21 22
851−0048−01 862−0015 815−0261
3 3 2
23 24 25 26 27 28 29 30
319−5102−04 1 821−6002−03 10 337−3623 1 337−3631 1 337−3625 1 098−7701 1 098−7700 1 098−8149 1
PART DESCRIPTION
REF NO.
Breaker, Circuit − 3 Pole − 600 Amp (UL & IEC) Includes Mounting Hardware Box, Circuit Breaker Panel, Terminal Cover, Circuit Breaker − Top Cover, Circuit Breaker − Bottom Screw, Hex Head (M8 x 1.25 x 20) Cover, Circuit Breaker Left Side Installation Right Side Installation Cup, Switch Bracket, Circuit Breaker Label, Information − Service Disconnect Standoff, Insulator Washer, Lock − Split (3/8) Screw, Cap − Hex Head (3/8−16 x .75) Bus, Bar − Ground Washer, Flat Washer, Belleville (3/8) Screw, Cap − Hex Head (3/8−16 x 1”) Lug, Solderless Screw, Cap − Hex Head (5/16−18 x 1”) Washer, Belleville (5/16) Nut, Hex (5/16) Screw, Hex Washer Head − Thread Forming (1/4−20 x .50) Stiffener, Cover Screw, Hex Head (M6 x 1 x 20) Bus, Bar − Neutral Bus, Bar − Neutral Bus, Bar − Jumper Label, Neutral Disconnect Label, Bonding − Jumper Label, Information − Lug Installation
31 32 33
QTY USED
098−6635 098−6865
1 1
098−5854−06 098−5854−07 098−5854−08 098−5854−09 098−5854−10
4 1 1 1 1
35
226−4894−08 226−4894−02 226−4894−05 226−4894−06 800−2114
4 4 6 6 5
36 37 38 39 40
860−2010 850−2012 526−2140 337−3736 800−0030
5 5 10 1 2
41
800−2063
2
42
800−0049
2
43 44
319−5128−02 821−6003−01
1 4
45 46
332−1557 800−0053
1 2
47 48
862−0003 508−1109
2 −
49
821−6003−03
6
50
098−8167
1
34
60
PART NO.
PART DESCRIPTION Label, Ground Label, Conduit Location Label, Marker (10 Characters Per Card) (Quantity Used As Required) Marked “L” Marked “1” Marked “2” Marked “3” Marked “0” Lead (Quantity Used As Required) 23” 18” 28” 25” Screw, Cap − Hex Head (M12 x 1.75 x 40) Nut, Hex (M12) Washer, Lock − Split (M12) Washer, Flat (M12) Bus, Bar − Ground Screw, Cap − Hex Head (5/16−18 x 1-1/4) Screw, Cap − Hex Head (M8 x 50) Screw, Cap − Hex Head (3/8−16 x .88) Bracket, Circuit Breaker Screw, Hex Head (M8 x 1.25 x 16) Lug Screw, Cap − Hex Head (3/8−16 x 1.75) Nut, Hex − Heavy (3/8) Edging − Bulk (Order by the Foot − 3 Feet Required) Screw, Hex Head (M8 x 1.25 x 25) Label, Information
Circuit Breaker P-Frame 800−1200 Amp
50
52
49 31
15
11
30
40
14
17
12
16
4
11 12
17
38
16
13
41
28 29
18 21
2
27
20
13
44
12
19 39 9
16
22 43
25 11
26
48 8
42
43 17
16 7
6
23
44
24
51
6
6
47 48
45 46
5
1
35 33
36
45 46
3
37 34
32
61
Circuit Breaker P-Frame 800−1200 Amp REF NO.
PART NO.
QTY USED
1
2 3 4 5 6 7
320−2182 1 320−2183 1 319−5161−02 1 319−5084−02 1 319−5171−02 1 319−5088−02 1 821−6003−02 54
8 9 10
319−5176−04 319−5176−05 319−5078−05 319−5179−02 098−8144
1 1 1 1 1
11 12 13
332−2512 850−0050 800−0048
8 8 8
14 15 16 17
337−3632 1 526−0423 2 851−0048−02 10 6 800−0050
18 19
332−3039 800−0028
5 3
20 21 22
851−0048−01 862−0015 815−0261
5 5 2
23 24 25 26 27 28 29 30 31
319−5102−04 1 821−6002−03 10 337−3623 1 337−3631 1 337−3625 1 098−7701 1 098−7700 1 098−6635 1 098−6865 1
PART DESCRIPTION
REF NO.
Breaker, Circuit − 3 Pole (UL & IEC) 800 Amp 1200 Amp Box, Circuit Breaker Panel, Terminal Cover, Circuit Breaker − Top Cover, Circuit Breaker − Bottom Screw, Hex Head (M8 x 1.25 x 20) Cover, Circuit Breaker Left Side Installation Right Side Installation Cup, Switch Bracket, Circuit Breaker Label, Information − Service Disconnect Standoff, Insulator Washer, Lock − Split (3/8) Screw, Cap − Hex Head (3/8−16 x .75) Bus, Bar − Ground Washer, Flat Washer, Belleville (3/8) Screw, Cap − Hex Head (3/8−16 x 1”) Lug, Solderless Screw, Cap − Hex Head (5/16−18 x 1”) Washer, Belleville (5/16) Nut, Hex (5/16) Screw, Hex Washer Head − Thread Forming (1/4−20 x .50) Stiffener, Cover Screw, Hex Head (M6 x 1 x 20) Bus, Bar − Neutral Bus, Bar − Neutral Bus, Bar − Jumper Label, Neutral Disconnect Label, Bonding − Jumper Label, Ground Label, Conduit Location
PART NO.
QTY USED
32
33
4 1 1 1 1
34
226−4894−08 A/R 226−4894−02 A/R 800−2114 24
35 36 37 38 39
860−2010 850−2012 526−2140 337−3736 800−0030
24 24 24 1 2
40
800−2063
2
41
800−0049
2
42 43
332−1557 800−0053
1 2
44 45 46 47 48 49
862−0003 337−3629−01 337−3629−02 337−3628−01 337−3628−02
2 2 2 1 1
098−2304 098−2304−01
2 2
098−5347 098−5347−02 821−6003−03
1 1 6
098−8168 098−8169
1 1 1
50 51 52
62
098−5854−06 098−5854−07 098−5854−08 098−5854−09 098−5854−10
PART DESCRIPTION Label, Marker (10 Characters Per Card) (Quantity Used As Required) Marked “L” Marked “1” Marked “2” Marked “3” Marked “0” Lead (Quantity Used As Required) 23” 18” Screw, Cap − Hex Head (M12 x 1.75 x 40) Nut, Hex (M12) Washer, Lock − Split (M12) Washer, Flat (M12) Bus, Bar − Ground Screw, Cap − Hex Head (5/16−18 x 1-1/4) Screw, Cap − Hex Head (M8 x 50) Screw, Cap − Hex Head (3/8−16 x .88) Lug Screw, Cap − Hex Head (3/8−16 x 1.75) Nut, Hex − Heavy (3/8) Bus, Bar − Breaker Bus, Bar − Breaker Bus, Bar − Breaker Bus, Bar − Breaker Label, Warning English French Label, Danger English French Screw, Hex Head (M8 x 1.25 x 25) Label, Information 800 Amp 1200 Amp
Circuit Breaker R-Frame 1600−2500 Amp
68 67 20 51
50
12
14 15
21
15
46
38 23 26
2
37
25
34 35
27
32 33
18
13
36
1
17
15 14
24 65 9
44 45
32 16
47 48
13
64 39
14
21
4
66
19
22
8 22
21 7
6
28 29
69
6 6 58
5
59 49 55 53
56
54
3
32 33 31
57 30 10 52
60
44 45
40 41
42 43
62 61
63
63
Circuit Breaker R-Frame 1600−2500 Amp REF NO.
PART NO.
QTY USED
1
2 3 4 5 6 7
320−2164−03 1 320−2164−02 1 320−2164−01 1 319−5161−02 1 319−5084−02 1 319−5171−02 1 319−5088−02 1 821−6003−02 54
8 9 10 11
319−5176−04 319−5176−05 319−5078−04 319−5177−02 232−4131 098−8144
1 1 1 1 2 1
12 13 14 15
332−2744−07 332−2512 850−0050 800−0048
2 5 7 7
16 17 18
332−2743−07 850−0060 800−0090
1 1 1
19 20 21 22
337−3626 526−0423 851−0048−02 800−0050
1 2 7 3
23 24
332−3039 800−0028
7 5
25 26 27
851−0048−01 862−0015 815−0261
7 7 2
28 29 30 31
319−5102−03 1 821−6002−04 10 337−3618 6 800−0094 24
32 33 34 35 36 37 38 39
851−0048−03 28 862−0005 27 1 337−3623 337−3624 1 337−3631 2 337−3625 1 337−3627 1 800−0052 4
40
337−3620−02 337−3620−02
2 1
PART DESCRIPTION
REF NO.
Breaker, Circuit − 3 Pole (UL & IEC) (Includes Mounting Hardware) 1600 Amp 2000 Amp 2500 Amp Box, Circuit Breaker Panel, Terminal Cover, Circuit Breaker − Top Cover, Circuit Breaker − Bottom Screw, Hex Head (M8 x 1.25 x 20) Cover, Circuit Breaker Left Side Installation Right Side Installation Cup, Switch Bracket, Circuit Breaker Spacer, Mounting Foot Label, Information − Service Disconnect Standoff, Insulator Standoff, Insulator Washer, Lock − Split (3/8) Screw, Cap − Hex Head (3/8−16 x .75) Standoff, Insulator Washer, Lock − Split (1/2) Screw, Cap − Hex Head (1/2−13 x 1.00) Bus, Bar − Ground Washer, Flat Washer, Belleville (3/8) Screw, Cap − Hex Head (3/8−16 x 1”) Lug, Solderless Screw, Cap − Hex Head (5/16−18 x 1”) Washer, Belleville (5/16) Nut, Hex (5/16) Screw, Hex Washer Head − Thread Forming (1/4−20 x .50) Stiffener, Cover Screw, Hex Head (M6 x 1 x 20) Bus, Bar − Breaker Screw, Cap − Hex Head (1/2−13 x 2) Washer, Belleville (1/2) Nut, Hex (1/2) Bus, Bar − Neutral Bus, Bar − Neutral Bus, Bar − Neutral Bus, Bar − Jumper Bus, Bar − Neutral Screw, Cap − Hex Head (3/8−16 x 1.5) Bus, Bar − Breaker Left Side Insulation Right Side Insulation
41
QTY USED
337−3621−02 337−3621−02 337−3619−01 337−3619−02
2 1 1 1
337−3620−01 337−3620−01
1 2
46
337−3621−01 337−3621−01 800−0093
1 2 4
47 48 49
098−7701 098−7700 098−8149
1 1 1
50 51 52
098−6635 098−6865
1 1
098−5854−06 098−5854−07 098−5854−08 098−5854−09 098−5854−10
4 1 1 1 1
42 43 44 45
53
54
226−4894−08 A/R 226−4894−02 A/R 800−2114 30
55 56 57
860−2010 850−2012 526−2140
58
320−2196−01
59 60 61
320−2196−02 1 332−3949 8 800−0054 16
62 63 64 65
851−0022 862−0003 337−3736 800−0030
16 16 1 2
66
800−2063
2
098−2304 098−2304−01
2 2
098−5347 098−5347−02 821−6003−03
1 1 6
67 68 69
64
PART NO.
30 30 30 2
PART DESCRIPTION Bus, Bar − Breaker Left Side Insulation Right Side Insulation Bus, Bar − Breaker Bus, Bar − Breaker Bus, Bar − Breaker Left Side Insulation Right Side Insulation Bus, Bar − Breaker Left Side Insulation Right Side Insulation Screw, Cap − Hex Head (1/2−13 x 1.75) Label, Neutral Disconnect Label, Bonding − Jumper Label, Information − Lug Installation Label, Ground Label, Conduit Location Label, Marker (10 Characters Per Card) (Quantity Used As Required) Marked “L” Marked “1” Marked “2” Marked “3” Marked “0” Lead (Quantity Used As Required) 23” 18” Screw, Cap − Hex Head (M12 x 1.75 x 40) Nut, Hex (M12) Washer, Lock − Split (M12) Washer, Flat (M12) Accessories, Circuit Breaker: Switch − Used as a Trip Alarm or Auxiliary Contact 24 Volt Shunt Trip Lug, Cable − Solderless Screw, Cap − Hex Head (3/8−16 x 2.00) Washer, Spring (3/8) Nut, Hex (3/8) Bus, Bar − Ground Screw, Cap − Hex Head (5/16−18 x 1-1/4) Screw, Cap − Hex Head (M8 x 50) Label, Warning English French Label, Danger English French Screw, Hex Head (M8 x 1.25 x 25)
Labels − Circuit Breaker
1
2
3
6
REF NO. 1 2 3 4
PART NO.
5
4
7
QTY USED
098−7701 098−7700 098−6635
1 1 1
5
098−5854−06 098−5854−07 098−5854−08 098−5854−09 098−5854−10 098−8144
1 1 1 1 1 1
6 7
098−6865 098−8149
1 1
PART DESCRIPTION
8
REF NO.
Label, Neutral Disconnect Link Label, Bonding Jumper Label, Ground Label, Marker (10 Characters Per Card) (Quantity Used As Required) Marked “L” Marked “1” Marked “2” Marked “3” Marked “0” Label, Information (Service Disconnect) Label, Conduit Location Label, Information (Lug Installation)
8
65
PART NO.
098−8169
QTY USED
1
PART DESCRIPTION Label, Information P-Frame − 1200 Amp (150V Line to Neutral Maximum)
Wiring Harness AC
1
3
2
4
REF NO.
PART NO.
QTY USED
PART DESCRIPTION
REF NO.
Harness, AC (Includes Parts Listed Below) Housing, Plug and Cap
3 4
1
338−4317
1
2
323−1643−01
1
66
PART NO.
QTY USED
323−1644−03 1 323−1648 15
PART DESCRIPTION Housing, Plug and Cap Socket, Terminal
Wiring Harness Extension
1
4
6
3
7
2
10 8
12
11
9
16 14
17
15
13
REF NO.
PART NO.
QTY USED
1
338−4754
1
2 3 4 5
323−1888 323−1837 323−2351 323−2139
1 2 1 1
6 7 8
323−2350 1 323−1492 68 323−1835−02 85
PART DESCRIPTION
REF NO.
Harness, Extension (Includes Parts Listed Below) Connector, Boot Connector, Contact − 50 Place Connector, Plug − 2 Position Connector, Plug − 23 Position (Not Shown) Connector, Plug − 3 Position Contact, Socket Contact, Socket
9 10 11 12 13 14 15 16 17 18
67
PART NO. 323−1625 323−1493 323−1591 323−1491 098−7594−02 323−1503 323−1626 098−7594−01 323−2349 323−1843
QTY USED 1 1 6 5 1 1 1 1 3 2
PART DESCRIPTION Socket, Receptacle − 6 Pin Socket, Receptacle − 3 Pin Plug, Connector Terminal, Pin Label, Connector Wedge, Receptacle − 3 Pin Wedge, Receptacle − 6 Pin Label, Connector Relief, Strain − Straight Grommet (Not Shown)
Engine Wiring Harness
1
2
3
4
9
REF NO.
PART NO.
QTY USED
1
338−4755
1
2 3 4 5
323−1493 323−1503 416−1021−03 323−1502
1 1 2 1
5
6
10
PART DESCRIPTION Harness, Wiring − Engine (Includes the Following Parts) Plug (3 Pin) Wedge, Lock (3 Pin) Boot, Ring − Red Wedge, Receptacle (3 Pin)
68
7
8
11
REF NO.
PART NO.
QTY USED
6 7 8 9 10 11
323−1494 323−1492 323−2280 323−2277 323−2352 357−0030
1 3 3 6 1 1
PART DESCRIPTION Connector, Receptacle (3 Pin) Socket, Female Socket, Contact Contact, Socket Connector, Plug Diode
Emergency Stop Switch
3
1
4
2 8 7 5
6 9
REF NO.
PART NO.
QTY USED
1
2 3 4
405−7658−02 405−7997 818−0231−02 319−5125 331−0027
1 1 4 1 1
PART DESCRIPTION
REF NO.
Cover, Enclosure − Adapter Plug Steel Aluminum Rivet, Pop Cup, Switch Connector, Romex
69
PART NO.
QTY USED
5 6
338−4293 815−0918
1 2
7 8 9
308−0999 308−1177 818−0231−06
1 1 4
PART DESCRIPTION Harness, Switch − E-Stop Screw, Machine − Flat Head − Cross Recessed (#6−32 x .62) Switch, Push Button − E-Stop Bezel, Switch Rivet, Pop
24VAC Transformer
4 1 3 4 3 5
2
REF NO.
PART NO.
QTY USED
1 2
315−1613 815−0959−03
1 5
PART DESCRIPTION
REF NO.
Transformer, Control Screw, Cross Recessed − Pan Head − W/ET (M3 x 0.5 x 8)
3 4 5
70
PART NO. 850−2003 860−2053 854−0006
QTY USED 5 5 1
PART DESCRIPTION Washer, Lock − Split (M3) Nut, Hex (M3 x 0.5) Washer, Lock − W/EIT (#6)
Inlet Louver Weather Steel Enclosure
8 4
2 3
7 10 9 6 5 1
71
Inlet Louver Weather Steel Enclosure REF NO.
PART NO.
1
QTY USED 1
179−4215 179−4215−01
1 1
2
405−8523−01
1
3
405−8523−02
1
4
821−6007−02 25
PART DESCRIPTION
REF NO.
Louver, Inlet (See Separate Page for Components) No Operating Louvers Spring Open and Spring Closed Louver, Operating Inlet (Spring Open) Louver, Operating Inlet (Spring Closed) Screw, Hex Head (M8 x 1.25 x 20)
QTY USED
5 6
526−0249−01 800−2089
2 2
7
405−6693
−
405−6460−08 405−6460−09
1 2
338−4588−01 338−4589
1 1
8 9 10
72
PART NO.
PART DESCRIPTION Washer, Flat (7/16) Screw, Cap − Hex Head (M10 x 1.5 x 40) Seal, Enclosure − Bulk (Order by the Foot − 26 Feet Required) Gasket, Door Gasket, Door Harness, Extension − Actuator AC/DC AC Only
Inlet Louver Components Weather Steel Enclosure 3 12
13
9 8
7
10
6
4
2
1
5
10
73
11
Inlet Louver Components Weather Steel Enclosure REF NO. 1 2 3 4 5 6 7 8
PART NO.
QTY USED
405−8863−02 1 405−8864−02 1 405−8865−02 1 405−8866−02 15 405−8867−02 1 405−8945−02 2 405−8948−02 2 405−8946−02 2
PART DESCRIPTION
REF NO.
Frame, Louver − Right Frame, Louver − Light Frame, Louver − Top Louver Frame, Louver − Center Frame, Louver − Gusset Frame, Louver − Retainer Mesh Frame, Louver − Lifting Eye
74
PART NO.
QTY USED
9 10 11
405−8639 2 405−8950−02 2 821−6006−01 124
12
821−6007−02 26
13
406−0929
63
PART DESCRIPTION Grill, Enclosure (With Mesh) Louver − Filler (With Mesh) Screw, Hex Head (M6 x 1.0 x 16) Screw, Hex Head (M8 x 1.25 x 20) Clip, Panel (With Mesh)
Louver Level 1 and 2 Steel Enclosure 12
24 11
4 6 25
8 3
9 8 10
21 22
14 15
2
17
23
13 23 1 19
6
18 20
11 5
16
75
7
13
14 15
Louver Level 1 and 2 Steel Enclosure REF NO.
PART NO.
QTY USED
1 2 3 4 5 6 7 8 9 10 11 12
405−8617−02 1 405−8616−02 1 405−8563−02 1 405−8551−02 1 405−8631−02 1 405−8562 2 405−8552−02 2 405−8561 18 405−8553 9 405−8559−02 9 405−8558 2 821−6007−02 126
13
405−8639
2
14
405−6460−08
1
15
405−6460−09
2
PART DESCRIPTION
REF NO.
Frame, Louver − Right Frame, Louver − Left Spacer, Panel − Splitter Frame, Louver − Top Frame, Louver − Bottom Retainer, Insulation − Half Frame, Louver − Lift Retainer, Insulation − Splitter Insulation, Sound − Splitter Louver − Splitter Insulation, Sound − Half Screw, Hex Head − Stainless Steel (M8 x 1.25 x 20) Grill, Enclosure − Mesh (No Operating Louvers) Gasket, Door (No Operating Louvers) Gasket, Door (No Operating Louvers)
16 17 18 19
818−0231−06 40 818−1173−01 266 526−0249−01 16 800−2089 8
20 21
860−2009 405−8523−01
8 1
22
405−8523−02
1
23
895−0414
−
24
338−4588−01
1
25
338−4589
1
76
PART NO.
QTY USED
PART DESCRIPTION Rivet, Pop Rivet, Flange Head − Blind Washer, Flat (7/16) Screw, Cap − Hex Head (M10 x 1.5 x 40) Nut, Hex (M10 x 1.5) Louver (Operating Inlet) (Spring Open) Louver (Operating Inlet) (Spring Closed) Seal, Enclosure (Inlet) − Bulk (Order by the Foot − 26 Feet Required) Harness, Extension − Actuator (Inlet Spring Open or Closed) Harness, Extension − Actuator (Inlet Spring Open)
Muffler Cover Weather Steel Enclosure 4
3
2
7
6
5
1
REF NO.
PART NO.
QTY USED
PART DESCRIPTION
REF NO.
1 2 3 4
155−4339−02 155−4340−02 405−8073−02 405−8567−02
1 1 1 1
Bracket, Muffler − Right Hand Bracket, Muffler − Left Hand Stiffener, Roof − Truss Panel, Roof − Muffler − Weather
5 6 7
77
PART NO.
QTY USED
155−4341−02 1 155−4348−02 1 821−6007−02 66
PART DESCRIPTION Cover, Exhaust Cover, Exhaust − Bottom Screw, Hex Head (M8 x 1.25 x 20)
This Page Intentionally Left Blank.
78
Muffler Cover Sound Steel Enclosure
2 12
3 9
5 7
6 11 8 13 14 15 4 8
1 10 79
Muffler Cover Sound Steel Enclosure REF NO.
PART NO.
QTY USED
PART DESCRIPTION
1 2
405−8569−02 405−8703−02
1 1
3 4
405−8073−02 405−8570−02
1 1
5 6
405−8819 405−8702−02
2 1
7 8
518−0581 800−2089
9
821−6007−02 36
^ Panel, Duct − Muffler Box ^ Panel, Roof − Muffler Box − Sound Stiffener, Roof − Truss Panel, Duct − Bottom − Muffler Box ^ Insulation, Duct − Muffler ^ Panel, Duct − Muffler Box − Left Hand ^ Nut, Push On Screw, Cap − Hex Head (M10 x 1.5 x 40) Screw, Hex Head (M8 x 1.25 x 20)
20 9
REF NO.
PART NO.
PART DESCRIPTION * Panel, Duct − Muffler Box * Panel, Duct − Muffler Box − Left Hand * Panel, Roof − Muffler Box − Weather Washer, Flat (7/16) Washer, Lock − Split (M10) Nut, Hex (M10 x 1.5)
10 11
405−8569−02 405−8702−04
1 1
12
405−8567−02
1
13 14 15
526−0249−01 850−2010 860−2009
8 4 4
* − Level 1 ^ − Level 2
80
QTY USED
Floor Installation
2 1
4
3
6 5
REF NO.
PART NO.
QTY USED
PART DESCRIPTION
REF NO.
1 2 3 4
405−8742 405−8743 405−8741−02 405−8744
1 1 1 1
Panel, Access − Left Hand Panel, Access − Right Hand Crossmember, Panel Panel, Access − Front
5
821−6003−02
6
815−0709−01 17
81
PART NO.
QTY USED 4
PART DESCRIPTION Screw, Hex Head (M8 x 1.25 x 20) Screw, Hex Head − Flange (M8 x 1.25 x 18)
Enclosure Lighting
4 6 7 3
1
5
2
REF NO.
PART NO.
QTY USED
1 2 3 4
179−4148 319−5641−02 319−5642−02 331−0602
1 2 2 5
PART DESCRIPTION
REF NO.
Lighting Assembly Plate, Mounting − Switch Plate, Mounting − Switch Clamp, Conduit
82
PART NO.
QTY USED
5 6
818−0231−02 24 800−6294 5
7
526−0179
5
PART DESCRIPTION Rivet, Pop Screw, Hex − Flange Head − Thread Forming (#8 x 5/8”) Washer, Flat (3/16)
Mounting System 17 14
18 20 3 19
21 13
10 9
22
15
16
23
8 1
11 12
26 5 6
REF NO. 1
2
PART NO.
QTY USED
403−5557−02 403−5603−02 403−5606−02
1 1 1
3 4 5
402−0859 10 402−0691−03 10 403−3362 20 526−0219 A/R 800−0093 40
6 7 8 9 10 11
862−0016 A/R 850−0060 A/R 502−1530 2 503−2350−04 4 503−1137 3 800−0098 10
12
403−5644−02 10
PART DESCRIPTION
REF NO.
Base, Skid − Lifting Weather Protective Enclosure Level 1 Enclosure Level 2 Enclosure Isolator, Vibration Seismic Standard Washer, Bevel Washer, Flat (1/2) Screw, Cap − Hex Head (1/2−13 x 1.75) − Seismic Nut, Hex (1/2−13) Washer, Lock − Split (1/2) Union, Hose (1”) − Nylon Hose, Coolant (1” x 5‘) Clamp, Hose Screw, Cap − Hex Head (1/2−13 x 3.0) Spacer, Lifting Bracket (Trans)
83
PART NO.
QTY USED
13 14 15 16
416−1301−02 416−1056−02 416−1057−02 821−6003−02
2 2 4 8
17 18 19
856−0030 337−0090−02 800−2087
4 1 5
20 21 22 23 24
526−2132 853−2010 098−7877 416−1302−02 860−2009
9 2 1 1 4
25 26 27
526−0027 10 403−5697−02 10 800−0095 20
7
3
2 27
4
PART DESCRIPTION Box, Battery Holddown, Battery Rod, Battery Holddown Screw, Hex Head (M8 x 1.25 x 20) Nut, Wing (M6) Strap, Electrical Screw, Cap − Hex Head (M10 x 30) Washer, Flat (M10) Washer − W/ET (M10) Label, Battery Warning Bracket, Battery Nut, Hex (M10 x 1.5) (Not Shown) Washer, Flat (3/4”) (Not Shown) Plate, Skid − Standard Isolator Screw, Cap − Hex Head (1/2−13 x 2)
Outlet Louver Auto
5
1 7 8
2 6 9 10
3
4
REF NO.
PART NO.
QTY USED
2
405−8732 405−8634−01 405−8634−02 821−6007−02
1 1 1 2
3
338−4588−01
1
4 5
307−2817−02 338−4589
1 1
1
PART DESCRIPTION
REF NO.
Louver − Auto Damper Gravity Spring Open Spring Closed Screw, Hex Head (M8 x 1.25 x 20) Harness, Extension − Actuator (Includes Relay) Relay − 24VDC Harness, Extension − Actuator − Spring Open
84
PART NO.
QTY USED
6 7
405−9275−02 1 821−6006−01 22
8 9
870−2054 800−2044
22 2
10
405−7754
1
PART DESCRIPTION Bracket, Duct − Actuator Screw, Hex Head (M6 x 1.0 x 16) Nut, Lock − Flange (M6 x 1) Screw, Cap − Hex Head (M6 x 1 x 70) Louver, Actuator
Louver Level 1 and 2 Aluminum Enclosure 12
24 11
4 6 25
8 3
9 8 10
21 22
14 15
2
17
23
13 23 1 19
6
18 20
11 5
26 16
85
7
13
14 15
Louver Level 1 and 2 Aluminum Enclosure REF NO.
PART NO.
QTY USED
1 2 3 4 5 6 7 8 9 10 11 12
405−8788 1 405−8787 1 405−8563−02 1 405−8784 1 405−8785 1 405−8562 2 405−8789 2 405−8561 18 405−8553 9 405−8790 9 405−8558 2 821−6007−02 126
13
405−8639
2
14
405−6460−08
1
15
405−6460−09
2
PART DESCRIPTION
REF NO.
Frame, Louver − Right Frame, Louver − Left Spacer, Panel − Splitter Frame, Louver − Top Frame, Louver − Bottom Retainer, Insulation − Half Frame, Louver − Lift Retainer, Insulation − Splitter Insulation, Sound − Splitter Louver − Splitter Insulation, Sound − Half Screw, Hex Head − Stainless Steel (M8 x 1.25 x 20) Grill, Enclosure − Mesh (No Operating Louvers) Gasket, Door (No Operating Louvers) Gasket, Door (No Operating Louvers)
16 17 18 19
818−0231−06 4 818−1173−01 252 526−0249−01 16 800−2089 8
20 21
860−2009 405−8523−01
8 1
22
405−8523−02
1
23
895−0414
−
24
338−4588−01
1
25
338−4589
1
26
818−1157
36
86
PART NO.
QTY USED
PART DESCRIPTION Rivet, Pop Rivet, Flange Head − Blind Washer, Flat (7/16) Screw, Cap − Hex Head (M10 x 1.5 x 40) Nut, Hex (M10 x 1.5) Louver (Operating Inlet) (Spring Open) Louver (Operating Inlet) (Spring Closed) Seal, Enclosure (Inlet) − Bulk (Order by the Foot − 26 Feet Required) Harness, Extension − Actuator (Inlet Spring Open or Closed) Harness, Extension − Actuator (Inlet Spring Open) Rivet, Flange Head − Blind
Inlet Louver Weather Aluminum Enclosure
4
8 10
2 3 1
7
11
9 12 13 14 15
87
6 5
Inlet Louver Weather Aluminum Enclosure REF NO.
PART NO.
1
QTY USED 1
2
179−4316−01 179−4316−02 405−8523−01
1 1 1
3
405−8523−02
1
4
821−6007−02 29
5 6
526−0249−01 800−2089
2 2
PART DESCRIPTION
REF NO.
Louver, Inlet (See Separate Page for Components) With Mesh Without Mesh Louver, Operating Inlet (Spring Open) Louver, Operating Inlet (Spring Closed) Screw, Hex Head (M8 x 1.25 x 20) Washer, Flat (7/16) Screw, Cap − Hex Head (M10 x 1.5 x 40)
7 8 9 10 11 12 13 14 15
88
PART NO.
QTY USED
PART DESCRIPTION
405−6693
−
405−6460−08 405−6460−09
1 2
338−4588−01 338−4589 405−9316−02 405−9317−02 870−2065−03 526−0451 800−2060
1 1 1 1 8 4 4
Seal, Enclosure − Bulk (Order by the Foot − 26 Feet Required) Gasket, Door Gasket, Door Harness, Extension − Actuator AC/DC AC Only Bracket, Enclosure − Louver Bracket, Enclosure − Louver Nut, Hex − Flange Washer, Flat − Stainless Steel Screw, Cap − Hex Head
Louver − F200−1
3
7 9
3 11 1 2
6 8 5 4
89
Louver − F200−1 REF NO.
PART NO.
QTY USED
1 2
A030L754 A032Y644
1 1
3
A030H999
27
4 5
526−0249−01 800−2089
2 2
PART DESCRIPTION
REF NO.
Louver Louver, Operating Inlet (Spring Open) Screw, Hex Head (M8 x 1.25 x 20) Washer, Flat (7/16) Screw, Cap − Hex Head (M10 x 1.5 x 40)
90
PART NO.
QTY USED
PART DESCRIPTION Seal, Enclosure − Bulk (Order by the Foot − 26 Feet Required) Gasket, Door Gasket, Door Harness, Extension − Actuator AC/DC AC Only
6
405−6693
−
7 8 9
405−6460−08 405−6460−09
1 2
338−4588−01 338−4589
1 1
Muffler Cover Weather Aluminum Enclosure 4
3
2
7
6
5
9
1
8
REF NO.
10
12
11 PART NO.
QTY USED
PART DESCRIPTION
REF NO.
Bracket, Muffler − Right Hand Bracket, Muffler − Left Hand Stiffener, Roof − Truss Panel, Roof − Muffler − Weather Cover, Exhaust Cover, Exhaust − Bottom
7
1 2 3 4
155−4452 155−4453 405−9034 405−9035
1 1 1 1
5 6
155−4455 155−4454
1 1
8 9 10 11 12
91
PART NO.
QTY USED
821−6007−02 70 405−9316−02 405−9317−02 870−2065−03 526−0451 800−2060
1 1 8 4 4
PART DESCRIPTION Screw, Hex Head (M8 x 1.25 x 20) Bracket, Enclosure − Louver Bracket, Enclosure − Louver Nut, Hex − Flange Washer, Flat − Stainless Steel Screw, Cap − Hex Head
This Page Intentionally Left Blank.
92
Muffler Cover Sound Aluminum Enclosure 2 9
3 8
14
5
13
6
4 10 7
12
11
1
93
Muffler Cover Sound Aluminum Enclosure REF NO.
PART NO.
QTY USED
PART DESCRIPTION
REF NO.
Panel, Duct − Muffler Box ^ Panel, Roof − Muffler Box − Sound Stiffener, Roof − Truss Panel, Duct − Bottom − Muffler Box ^ Insulation, Duct − Muffler Panel, Duct − Muffler Box − Left Hand Screw, Cap − Hex Head (M10 x 1.5 x 40) Screw, Hex Head (M8 x 1.25 x 20)
9
1 2
405−9048 405−9049
1 1
3 4
405−9050 405−9051
1 1
5 6
405−8819 405−9053
2 1
7
800−2089
9
8
821−6007−02 56
10 11 12 13 14
PART NO. 405−9054
1
526−0249−01 8 850−2010 4 860−2009 4 405−9199 6 821−6006−01 12
* − Level 1 ^ − Level 2
94
QTY USED
PART DESCRIPTION * Panel, Roof − Muffler Box − Weather Washer, Flat (7/16) Washer, Lock − Split (M10) Nut, Hex (M10 x 1.5) ^ Bracket, Enclosure − Panel ^ Screw, Hex Head − Stainless Steel (M6 x 1 x 16)
Fuel Pump
2 1
5
3 4
REF NO. 1
PART NO.
QTY USED
149−2758−01 149−2758−02 149−2758−03 149−2758−04
1 1 1 1
PART DESCRIPTION
REF NO.
Pump, Fuel 200−600 Gallon 1000 Gallon 1500−2400 Gallon 3000 Gallon
95
PART NO.
QTY USED
2 3 4
860−2010 526−0219 800−2112
2 2 2
5
850−2012
2
PART DESCRIPTION Nut, Hex Washer, Flat Screw, Cap − Hex Head (M12 x 30) Washer, Lock − Split
AC Circuit Breaker Box
1
5
2 3
4
REF NO. 1 2
PART NO.
QTY USED
320−2281−02 320−2281−01 860−2009
1 1 4
PART DESCRIPTION Breaker, Circuit − Assembly With Heater Cables Without Heater Cables Nut, Hex (M10 x 1.5)
96
6
ÂÂ ÂÂ ÂÂ ÂÂ
REF NO.
PART NO.
QTY USED
3 4 5 6
850−2010 337−3466−01 319−5774−02 331−0625
4 1 1 8
PART DESCRIPTION Washer, Lock − Split (M10) Strap, Bond Spacer, Control − Heater Clamp, Conduit
15 Amp Charger Mounting
9
6 5 10
2 3
1 4
7
REF NO.
PART NO.
QTY USED
1 2 3 4
300−5878−01 319−5992−02 821−6002−03 821−6001−02
1 1 7 4
5
098−6161
1
PART DESCRIPTION
REF NO.
Charger, 15 Amp Cover, Control Screw, Hex Head (M6 x 1 x 16) Screw, Hex Head (M5 x 0.8 x 12) Label, Danger
6 7 8 9 10
97
PART NO.
QTY USED
PART DESCRIPTION
098−7614 098−6162 331−0027
1 1 2
338−4300−03 335−0173−06
1 1
Label, Caution Label, Warning Connector, Romex (1/2”) (Not Shown) Harness, Battery Charger Cable
External Receptacle
7
10
8
1 6 2
5
3
4
11
9
REF NO.
PART NO.
QTY USED
PART DESCRIPTION Box, Outlet Connector, Receptacle Connector, Liquidtite Conduit, Liquid Tight − Bulk (Order by the Foot − 10 Feet Required) Harness, Wiring − Receptacle
1 2 3 4
330−0156 323−2101 331−0559 331−0601
1 1 2 −
5
338−4385−02
1
REF NO. 6 7 8 9 10 11
98
PART NO. 330−0157 330−0158 870−0183 518−0703 098−8185 812−0068
QTY USED 1 1 4 5 1 4
PART DESCRIPTION Cover, Receptacle Cover, Outlet Box − Blank Nut, Hex − W/ET (#6−32) Clamp, J Label, Information Screw, Hex Head (#6−32 x 1.0)
Air Duct DQFAA, DQFAB, DQFAC
2
3 1
5
4
6
REF NO.
PART NO.
QTY USED
PART DESCRIPTION
REF NO.
1 2 3 4
405−8748−02 405−8746−02 405−8747−02 130−6307−01
2 1 1 2
Duct, Air (Vertical) Duct, Air (Horizontal Top) Duct, Air (Horizontal Bottom) Seal, Radiator (Duct)
5 6
99
PART NO.
QTY USED
130−6307−02 821−6003−02
2 8
PART DESCRIPTION Seal, Radiator (Duct) Screw, Hex Head (M8 x 1.25 x 20)
Air Duct DQFAD
1
2 3
5
4
6
REF NO.
PART NO.
QTY USED
PART DESCRIPTION
REF NO.
1 2 3 4
405−8564−02 405−8565−02 405−8566−02 130−6307−01
1 1 2 2
Duct, Air (Horizontal Top) Duct, Air (Horizontal Bottom) Duct, Air (Vertical) Seal, Radiator (Duct)
5 6
100
PART NO.
QTY USED
130−6307−02 2 821−6003−02 16
PART DESCRIPTION Seal, Radiator (Duct) Screw, Hex Head (M8 x 1.25 x 20)
Key Operator Switch
2 1
REF NO. 1
PART NO. 308−1045
QTY USED 1
PART DESCRIPTION
REF NO.
Switch, Key Operator
2
101
PART NO. 308−1046
QTY USED 2
PART DESCRIPTION Key
Battery Cover
2
4
3
3
1
REF NO.
PART NO.
QTY USED
PART DESCRIPTION
REF NO.
PART NO.
QTY USED
1 2
416−1085−02 821−6003−01
1 6
Bracket, Cover Screw, Hex Head (M8 x 1.25 x 16)
3 4
416−1068−01 098−5338
2 2
102
PART DESCRIPTION Cover, Battery Tray Label, No Step
Labels Miscellaneous
1
2
6
3
7
4
8
5
9
11
10
14 12 15 13
16
17
18
2
20
25
19
21
22 23
103
24
Labels Miscellaneous REF NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17
PART NO.
QTY USED
098−4730 A/R 098−4500 2 098−4798 6 098−4732 2 098−5842 1 098−5347 3 098−5759 2 098−7614 6 098−7902−03 2 098−6074−02 1 098−7881 2 098−5387 1 098−1837−01 1 098−7486−01 2 098−7487−01 2 098−7878 1 098−8389 A/R
PART DESCRIPTION
REF NO.
Label, Warning Label, Prototype Tested Label, Warning Label, Warning Label, Caution Label, Danger Label, Warning Label, Warning Label, Logo Label, Warning Label, Warning Label, Danger Label, Oil Drain Label, Warning − Lifting Label, Warning − Overturning Label, Fuse (20A) Label, Warning − Rigging
104
PART NO.
QTY USED
18 19 20 21
098−7902−06 A/R 098−7913−02 A/R 098−7451 A/R 098−8194 A/R
22 23 24 25
098−4732 098−7868 098−8185 098−7883−01 098−7883−02 098−7883−04 098−7883−05 098−7883−07 098−7883−08 098−7883−09 098−7883−10
A/R A/R A/R 1 1 1 1 1 1 1 1
PART DESCRIPTION Label, Logo Label, Logo Label, Caution Label, Information − Crankcase Vent Label, Warning Label, Enclosure Label, Information Label, Insert Portuguese French Dutch German Swedish Italian Czech Finnish
Numerical Index Part No.
Page
Part No.
Page
Part No.
Page
Part No.
Page
098−1837−01, 104
098−7877, 83
130−4570, 20
130−5722−02, 24
098−2235−02, 18
098−7878, 104
130−4893−03, 24
130−5723−02, 24
098−2304, 62 , 64
098−7881, 104
130−4893−04, 24
130−5724−02, 24
098−2304−01, 62 , 64
098−7883−01, 104
130−4943−02, 24
130−5725−02, 24
098−4500, 104
098−7883−02, 104
130−4944, 24
130−5727−02, 24
098−4730, 104
098−7883−04, 104
130−4982, 20
130−5728−02, 24
098−4732, 104
098−7883−05, 104
130−4992−02, 24
130−5729−02, 24
098−4798, 104
098−7883−07, 104
130−5010−02, 24
130−5769, 24 , 25
098−5338, 102
098−7883−08, 104
130−5011−02, 20
130−5784−02, 24
098−5347, 16 , 36 , 62 , 64 , 104
098−7883−09, 104
130−5016−02, 24
130−5785−02, 24
098−7883−10, 104
130−5021−02, 22
130−5786−02, 24
098−7902−03, 104
130−5022−02, 22
130−5787−02, 24
098−7902−06, 104
130−5023−02, 22
130−6255−02, 16
098−7913−02, 104
130−5024−02, 22
130−6256−02, 16
098−8120, 9
130−5025−02, 22
130−6257−02, 16
098−8121, 49
130−5039−02, 20
130−6258−02, 16
098−5854−07, 60 , 62 , 64 , 65
098−8144, 60 , 62 , 64 , 65
130−5086−02, 24
130−6260−02, 16
098−8149, 60 , 64 , 65
130−5210, 24
130−6291−02, 5
098−5854−08, 60 , 62 , 64 , 65
098−8157, 54
130−5286−02, 24
130−6307−01, 99 , 100
098−5854−09, 60 , 62 , 64 , 65
098−8167, 60
130−5692, 24
130−6307−02, 99 , 100
098−8168, 62
130−5692−01, 25
130−6555, 25
098−5854−10, 60 , 62 , 64 , 65
098−8169, 62 , 65
130−5692−02, 25
130−7026−01, 7
098−8184, 54
130−5692−03, 25
130−7026−02, 6 , 7
098−6074−02, 104
098−8185, 98 , 104
130−5692−04, 25
130−7078, 6 , 7
098−6161, 97
098−8186, 44 , 45
130−5692−05, 25
133−0226, 16
098−6162, 97
098−8194, 104
130−5692−06, 25
140−1260, 6 , 7
098−6195, 16 , 46
098−8389, 104
130−5692−08, 25
140−1548, 6 , 7
098−6635, 36 , 49 , 60 , 62 , 64 , 65
123−2142−02, 24
130−5692−09, 25
140−2096, 7
128−0108, 16
130−5692−10, 25
140−2097, 7
130−0449, 20
130−5692−11, 25
140−2098, 7
130−3592−01, 20
130−5692−12, 25
140−2099, 7
130−3592−02, 20
130−5692−13, 25
140−2467, 7
130−3660−01, 22
130−5692−14, 25
140−2502, 6
130−3766, 20
130−5692−15, 25
140−3163, 6
130−3769, 20
130−5692−16, 25
140−3370, 8
130−3770, 20
130−5692−17, 25
140−3990−02, 6 , 7
130−3772, 20
130−5692−18, 25
140−3993−02, 6 , 7
130−3773, 20
130−5692−19, 25
140−3994−02, 6 , 7
130−3969, 20
130−5692−21, 25
149−2758−01, 95
130−4546, 16
130−5692−22, 25
149−2758−02, 95
130−4552, 18
130−5692−23, 25
149−2758−03, 95
098−5347−02, 36 , 62 , 64 098−5387, 104 098−5759, 104 098−5842, 104 098−5854−06, 60 , 62 , 64 , 65
098−6865, 60 , 62 , 64 , 65 098−7244, 18 098−7451, 104 098−7486−01, 104 098−7487−01, 104 098−7594−01, 67 098−7594−02, 67 098−7614, 97 , 104 098−7700, 60 , 62 , 64 , 65 098−7701, 60 , 62 , 64 , 65 098−7719−01, 56 098−7720−01, 54 098−7868, 104
105
Numerical Index Part No.
Page
Part No.
Page
Part No.
Page
Part No.
Page
149−2758−04, 95
200−3051−07, 42
302−2057−36, 51
319−5078−06, 60
155−0899, 20
200−3052−01, 42
302−2057−37, 51
319−5079, 50
155−2351, 12 , 13
200−3052−02, 42
302−2057−38, 51
319−5081−02, 38
155−2503, 20
200−3052−03, 42
302−2057−39, 51
319−5082−02, 38
155−2514, 20
200−3052−07, 42
302−2057−41, 51
319−5083−02, 37 , 38
155−2514−02, 20
200−3053−01, 42
302−2057−42, 51
155−2531−04, 54
200−3053−02, 42
302−2057−49, 51
319−5084−02, 36 , 60 , 62 , 64
155−3021, 16
200−3053−03, 42
305069200, 5
155−3372, 24
200−3053−07, 42
306−3467, 28 , 30 , 32
155−3543, 12 , 13
200−3128−01, 42
306−4966, 28 , 30 , 32
155−4313, 12
200−3128−02, 42
307−1056, 53
155−4314, 13
200−3128−19, 42
307−2711, 20
155−4315, 13
226−4115, 20
307−2817−02, 9 , 18 , 84
155−4317−02, 12 , 13
226−4894−02, 60 , 62 , 64
307−2859, 18
155−4339−02, 77
226−4894−05, 60
307−3003−01, 57
155−4340−02, 77
226−4894−06, 60
308−0973, 9
155−4341−02, 77
226−4894−08, 60 , 62 , 64
308−0999, 48 , 69
155−4344, 12 , 13
232−3849, 41
308−1045, 101
319−5161−02, 36 , 60 , 62 , 64
155−4348−02, 77
232−3938, 22
308−1046, 101
319−5162−02, 36
155−4382, 12 , 13
232−3939, 22
308−1085, 48
319−5163−02, 36
155−4396−02, 12 , 13
232−3941−01, 39 , 40
308−1085−01, 48
155−4396−05, 12 , 13
232−3941−02, 39 , 40
308−1105, 56
319−5171−02, 36 , 60 , 62 , 64
155−4412−02, 12 , 13
232−3941−03, 39 , 40
308−1177, 69
155−4414−01, 12 , 13
232−3941−04, 39 , 40
309−0649, 16
155−4415−01, 12
232−4001, 22
309−0665, 20
155−4415−02, 13
232−4131, 64
315−1605−01, 57
155−4452, 91
300−4306, 48
315−1613, 70
155−4453, 91
300−4308−01, 52
315−1621, 57
155−4454, 91
300−4308−02, 52
315−1622, 57
155−4455, 91
300−4308−03, 52
319−2236, 5
179−4148, 82
300−4985−01, 55
319−4787−02, 18
179−4215, 72
300−4985−02, 55
319−4788−02, 16
179−4215−01, 72
300−4985−03, 55
319−4918−02, 48
179−4316−01, 88
300−4985−04, 55
319−5014−02, 49
179−4316−02, 88
300−5179, 48
319−5018−02, 48
191−2331−02, 24
300−5180, 48
319−5038−02, 57
193−0486, 14
300−5181, 48
319−5052−02, 44
193−0493−01, 54
300−5326, 50
319−5056−02, 9
200−3051−01, 42
300−5685−01, 48
319−5060, 55
200−3051−02, 42
300−5796, 54
319−5078−04, 64
200−3051−03, 42
300−5878−01, 97
319−5078−05, 62
106
319−5085−02, 38 319−5088−02, 36 , 60 , 62 , 64 319−5096−02, 50 319−5097−02, 37 , 38 319−5102−03, 64 319−5102−04, 36 , 60 , 62 319−5125, 69 319−5128−02, 60 319−5135−02, 49
319−5176−04, 60 , 62 , 64 319−5176−05, 60 , 62 , 64 319−5176−06, 36 319−5177−02, 64 319−5179−02, 36 , 60 , 62 319−5184−02, 38 319−5188−02, 37 , 38 319−5193, 48 319−5194, 48 319−5488−02, 38 319−5504−02, 37 319−5505−02, 37 319−5506−02, 37 319−5520−02, 44 319−5558−02, 44 319−5631−02, 44 319−5632−02, 44 319−5641−02, 82 319−5642−02, 82 319−5721−02, 37
Numerical Index Part No.
Page
Part No.
Page
Part No.
Page
Part No.
Page
319−5725−02, 37
323−1708, 14
332−1911, 48
337−3625, 60 , 62 , 64
319−5740−03, 51
323−1709, 14
332−2420, 24 , 57
337−3626, 64
319−5774−02, 96
323−1718, 18
332−2512, 60 , 62 , 64
337−3627, 64
319−5992−02, 97
323−1765, 14
332−2743−07, 64
337−3628−01, 62
320−1960−01, 60
323−1835−02, 67
332−2744−07, 64
337−3628−02, 62
320−2164−01, 64
323−1837, 67
332−2878, 49
337−3629−01, 62
320−2164−02, 64
323−1839, 48
332−2879−09, 49
337−3629−02, 62
320−2164−03, 64
323−1843, 67
332−3023, 41
337−3631, 60 , 62 , 64
320−2182, 62
323−1848, 50
332−3024−14, 41
337−3632, 60 , 62
320−2183, 62
323−1888, 67
332−3039, 60 , 62 , 64
337−3736, 60 , 62 , 64
320−2196−01, 64
323−1899−01, 56
332−3125−01, 46
338−3019, 51
320−2196−02, 64
323−2101, 98
332−3126−01, 46
338−3832, 14
320−2281−01, 96
323−2139, 67
332−3196, 40
338−4105−14, 18
320−2281−02, 96
323−2277, 68
332−3440, 18
338−4105−15, 18
322−0017, 48
323−2280, 68
332−3491−01, 48
338−4293, 69
322−0361, 48
323−2349, 67
332−3949, 64
338−4300−03, 97
322−0488, 48
323−2350, 67
332−4002, 46
338−4302, 49
322−0491, 56
323−2351, 67
333−0438−05, 41
338−4315, 49
322−0493−04, 56
323−2352, 68
333−0438−06, 41
338−4317, 66
322−0493−05, 56
326−0230, 48
333−0645−01, 46
338−4340−01, 54
322−0493−06, 56
327−0923, 5 , 16 , 39
333−0645−02, 46
338−4340−02, 54
323−1410−01, 53
327−1376−01, 50
333−0654, 56
338−4351, 56
323−1445, 18
327−1376−02, 50
333−0677−01, 16
338−4360−02, 9
323−1491, 14 , 18 , 67
327−1390, 50
333−0677−02, 16
338−4385−02, 98
323−1492, 18 , 67 , 68
327−1392, 50
333−0682, 9
338−4386, 57
323−1493, 67 , 68
330−0141−01, 41
333−0683−02, 9
338−4392, 18
323−1494, 18 , 68
330−0142, 41
333215900, 22
338−4408, 57
323−1500, 18
330−0156, 98
335−0173−06, 97
323−1502, 18 , 68
330−0157, 98
337−0049, 44 , 45 , 49
338−4588−01, 72 , 76 , 84 , 86 , 88 , 90
323−1503, 67 , 68
330−0158, 98
337−0090−02, 83
323−1504, 18
331−0027, 69 , 97
337−2953, 28 , 30 , 32
323−1547, 14
331−0042, 18
337−3466−01, 96
323−1549, 14
331−0555, 18
337−3618, 64
323−1591, 67
331−0559, 98
337−3619−01, 64
323−1625, 67
331−0601, 98
337−3619−02, 64
323−1626, 67
331−0602, 82
337−3620−01, 64
323−1643−01, 66
331−0625, 96
337−3620−02, 64
323−1644−03, 51 , 66
332−0052, 48 , 52
337−3621−01, 64
323−1648, 51 , 66
332−1468, 18
337−3621−02, 64
323−1652, 18
332−1469, 18
337−3623, 60 , 62 , 64
323−1688, 48
332−1557, 60 , 62
337−3624, 64
107
338−4589, 72 , 76 , 84 , 86 , 88 , 90 338−4649−01, 48 338−4649−02, 48 338−4754, 67 338−4755, 68 357−0030, 18 , 68 363−0183, 50 370−4038, 16 402−0354, 57 402−0666−01, 44 , 45 402−0691−03, 83 402−0729, 5
Numerical Index Part No.
Page
Part No.
Page
Part No.
Page
Part No.
Page
402−0859, 83
405−8494−02, 28 , 30
405−8641, 28 , 30 , 32
405−8866−02, 74
403−3362, 83
405−8495−02, 28 , 30
405−8642, 28 , 30 , 32
405−8867−02, 74
403−3846, 33
405−8523−01, 72 , 76 , 86 , 88
405−8643, 28 , 30 , 32
405−8878, 32
405−8644, 28 , 30 , 32
405−8879, 32
405−8645, 28 , 30 , 32
405−8880, 32
405−8646, 28 , 30 , 32
405−8881, 32
405−8647, 28 , 30 , 32
405−8892, 32
405−8702−02, 80
405−8893, 32
405−8702−04, 80
405−8894, 32
405−8703−02, 80
405−8895, 32
405−8727−01, 28 , 30 , 32
405−8896, 32
405−8727−02, 28 , 30 , 32
405−8897, 32
405−8732, 84
405−8898, 32
405−8737, 32
405−8899, 32
405−8741−02, 81
405−8900, 32
405−8742, 81
405−8910, 32
405−8743, 81
405−8911, 32
405−8744, 81
405−8912, 32
405−8746−02, 99
405−8913, 32
405−8747−02, 99
405−8914, 32
405−8748−02, 99
405−8915, 32
405−8766−02, 28 , 30
405−8916, 32
405−8767−02, 28 , 30
405−8945−02, 74
405−8777, 28 , 30 , 32
405−8946−02, 74
405−8778, 28 , 30 , 32
405−8948−02, 74
405−8784, 86
405−8950−02, 74
405−8785, 86
405−9020, 28 , 30 , 32
405−8787, 86
405−9021, 28 , 30 , 32
405−8788, 86
405−9034, 91
405−8789, 86
405−9035, 91
405−8790, 86
405−9048, 94
405−8811, 32
405−9049, 94
405−8812, 32
405−9050, 94
405−8819, 80 , 94
405−9051, 94
405−8836, 32
405−9053, 94
405−8837, 32
405−9054, 94
405−8838, 32
405−9114−02, 28 , 30
405−8839, 32
405−9145, 32
405−8863−02, 74
405−9179, 32
405−8864−02, 74
405−9199, 94
405−8865−02, 74
405−9275−02, 84
403−4211, 33 403−4239, 40 403−5557−02, 83 403−5603−02, 83 403−5606−02, 83 403−5644−02, 83 403−5697−02, 83 405−6000−16, 28 , 30 , 32 405−6000−17, 28 , 30 , 32 405−6000−18, 28 , 30 , 32 405−6000−19, 28 , 30 , 32 405−6000−20, 28 , 30 , 32 405−6460−08, 72 , 76 , 86 , 88 , 90 405−6460−09, 72 , 76 , 86 , 88 , 90
405−8523−02, 72 , 76 , 86 , 88 405−8536−02, 28 , 30 405−8537−02, 28 , 30 405−8538−02, 28 , 30 , 32 405−8539−02, 28 , 30 , 32 405−8551−02, 76 405−8552−02, 76 405−8553, 76 , 86 405−8554−02, 28 405−8555−02, 28 405−8556−02, 28 405−8558, 76 , 86 405−8559−02, 76 405−8561, 76 , 86
405−6693, 72 , 88 , 90
405−8562, 76 , 86
405−7658−02, 69
405−8563−02, 76 , 86
405−7754, 84
405−8564−02, 100
405−7779, 48
405−8565−02, 100
405−7882, 28 , 30 , 32
405−8566−02, 100
405−7883, 28 , 30 , 32
405−8567−02, 77 , 80
405−7884−02, 28 , 30 , 32
405−8569−02, 80
405−7885−02, 28 , 30 , 32
405−8570−02, 80
405−7997, 69
405−8573−02, 28 , 32
405−8071−02, 28 , 30
405−8608−02, 28
405−8072−02, 28 , 30
405−8609−02, 28 , 32
405−8073−02, 28 , 77 , 80
405−8615−02, 28 , 30 , 32
405−8074−02, 28
405−8616−02, 76
405−8075−02, 28
405−8617−02, 76
405−8076−02, 28
405−8631−02, 76
405−8077−02, 28
405−8633−02, 28 , 30
405−8078−02, 28
405−8634−01, 84
405−8079−02, 28 , 30
405−8634−02, 84
405−8080−02, 28 , 30
405−8635−02, 28
405−8081−02, 28 , 30
405−8636−02, 28
405−8083−02, 28 , 30
405−8637−02, 28
405−8084−02, 28
405−8639, 74 , 76 , 86
405−8493, 28 , 30 , 32
405−8640, 28 , 30 , 32
108
Numerical Index Part No.
Page
Part No.
Page
Part No.
Page
Part No.
Page
405−9316−02, 88 , 91
503−1726, 20
505−0019, 20
518−0703, 98
405−9317−02, 88 , 91
503−1728, 20
505−0020, 20
518−0704, 16
406−0810, 48
503−1729, 20
505−0044, 20
520−0544, 16
406−0916, 50
503−1762, 20
505−0050, 16
525−0304, 4
406−0917, 50
503−1870−10, 6
505−0100, 16
525−0305, 4
406−0929, 28 , 30 , 32 , 74
503−1870−11, 7 , 8
505−0102, 5
525−0306, 4
406−0930, 48
503−1870−14, 6 , 7 , 8
505−0103, 20
526−0003, 57
406−0932−02, 48
503−1870−16, 7 , 8
505−0180, 20
526−0008, 49
406−0972−03, 28 , 30 , 32
503−1872−01, 20
505−0324, 5
526−0018, 28 , 30 , 32 , 39
406−1075, 28 , 30 , 32
503−1872−02, 20
505−0382, 20
406−1082, 28 , 32
503−1872−04, 24
505−0601, 20
526−0027, 20 , 22 , 24 , 33 , 34 , 35 , 39 , 40 , 83
406−1089−02, 28 , 30 , 32
503−1872−05, 20
505−0607, 20
406−1090, 28 , 30 , 32
503−1872−07, 24
505−0667, 20
406−1091−02, 28 , 30 , 32
503−1872−09, 20
505−1090, 20
416−0639, 5
503−2102, 6 , 7 , 8
505−1429, 20
416−0680, 5
503−2112, 20
505−1441, 20
416−1019, 5
503−2113, 20
505−1442, 20
416−1021−03, 68
503−2114, 20
505−1508, 5
416−1056−02, 83
503−2115, 20
505−1547, 20
526−0249−01, 12 , 13 , 28 , 30 , 32 , 72 , 76 , 80 , 86 , 88 , 90 , 94
416−1057−02, 83
503−2116, 20
505−1549, 20
526−0324, 44 , 45
416−1068−01, 102
503−2118, 20
505−1553, 20
526−0399−05, 9
416−1085−02, 102
503−2123, 20
505−1576−02, 16
526−0399−28, 20
416−1096, 5
503−2124, 20
505−2138, 54
526−0399−60, 38
416−1301−02, 83
503−2130, 24
505−2164, 20
526−0416, 39 , 40
416−1302−02, 83
503−2132, 24
508−0228, 41
526−0423, 60 , 62 , 64
425−1799, 48
503−2135, 24
508−1090, 37 , 38
526−0444, 40
501−0520, 33 , 34 , 35
503−2157−02, 16
508−1109, 60
526−0451, 88 , 91
501−0522, 33 , 34 , 35
503−2267, 20
508−1186, 48
526−2120, 5 , 24
501−0744−03, 24
503−2268, 20
508−1195, 9
526−2132, 83
501−0744−10, 16
503−2350−04, 83
517−0021, 41
502−0827, 16
503−2519, 16
517−0133, 28 , 30 , 32 , 49
526−2140, 5 , 6 , 7 , 22 , 24 , 60 , 62 , 64
502−1146, 20
503−2556−05, 16
517−0138−02, 18
502−1162, 20
503−2823, 8
517−0138−08, 32
502−1514, 16
503−3062−01, 16
517−0350, 28 , 30 , 32
502−1530, 83
504−0028, 20
518−0340, 9
503−0685, 20
504−0171, 5
518−0350, 54
503−0970, 6
504−0175, 20
518−0548−08, 20
503−1133, 24
504−0213, 16
518−0548−15, 16
503−1137, 83
504−0214, 16
518−0548−24, 38
503−1418, 44 , 45
504−0215, 16
518−0581, 80
503−1485, 7 , 8
505−0011, 20
518−0601, 4
109
526−0049, 18 526−0113, 28 , 30 , 32 526−0115, 49 526−0128, 13 , 16 526−0179, 82 526−0219, 20 , 24 , 83 , 95
526−2303, 48 536−2140, 8 541−0809, 50 800−0028, 60 , 62 , 64 800−0030, 60 , 62 , 64 800−0048, 60 , 62 , 64 800−0049, 60 , 62 800−0050, 60 , 62 , 64 800−0052, 64 800−0053, 60 , 62 800−0054, 16 , 64
Numerical Index Part No.
Page
Part No.
Page
Part No.
Page
800−0090, 64
815−0447, 18
821−6004−01, 37 , 44
800−0092, 24
815−0539, 18
800−0093, 64 , 83
815−0651, 9
821−6006−01, 28 , 30 , 32 , 74 , 84 , 94
800−0094, 64
815−0709−01, 9 , 81
800−0095, 83
815−0776, 44 , 45
821−6007−02, 28 , 30 , 32 , 72 , 74 , 76 , 77 , 80 , 84 , 86 , 88 , 91 , 94
800−0098, 83
815−0793−02, 49
822−3047, 41
800−0160, 20
815−0796, 48
822−3075, 41
800−0161, 33 , 40
815−0918, 69
823−0001−01, 48
800−0163, 39
815−0937, 9
823−0002−05, 49
800−0310−68, 20
815−0947, 50
850−0025, 57
800−0310−69, 20
815−0948, 50
850−0050, 60 , 62 , 64
800−0310−79, 20
815−0949, 50
850−0060, 20 , 24 , 64 , 83
800−0310−81, 20
815−0959−03, 70
850−0070, 20
800−0310−97, 20
818−0231−02, 28 , 30 , 32 , 44 , 45 , 69 , 82
850−0079, 20 , 24 , 33 , 34 , 35 , 39 , 40
818−0231−06, 28 , 30 , 69 , 76 , 86
850−0114−07, 16
800−2008, 41 800−2044, 28 , 30 , 32 , 84 800−2060, 88 , 91 800−2061, 38 800−2063, 60 , 62 , 64 800−2085, 5 800−2087, 24 , 83 800−2089, 12 , 13 , 28 , 30 , 32 , 72 , 76 , 80 , 86 , 88 , 90 , 94
818−1150−02, 46 , 49 818−1157, 86 818−1173−01, 76 , 86 819−1157, 49 821−0010, 57 821−0017, 57 821−0030, 24
800−2095, 24
821−0033, 20
800−2110, 5
821−2045, 49
800−2112, 95
821−5002−03, 16
800−2113, 24
821−5003−03, 12 , 13 , 20 , 22 , 24
800−2114, 13 , 60 , 62 , 64 800−2201, 6 , 7 , 8 , 22 800−2543−05, 39 800−2543−06, 40 800−3017−52, 6 , 7 , 8 , 22 800−3017−56, 24 800−6294, 28 , 30 , 32 , 82 805−0035, 39 , 40 812−0068, 98 812−0082, 57 812−0094, 57 815−0181, 28 , 30 815−0203, 18 815−0261, 60 , 62 , 64
850−2003, 41 , 70 850−2004, 41 850−2005, 41 850−2010, 12 , 13 , 32 , 80 , 94 , 96
862−0003, 60 , 62 , 64 862−0005, 64 862−0007, 20 862−0008, 20 , 24 , 33 , 34 , 35 , 39 , 40 862−0015, 60 , 62 , 64 862−0016, 20 , 24 , 83 870−0114, 28 , 30 870−0131, 18 870−0183, 9 , 98 870−0212, 57 870−0221, 57 870−0257, 57 870−0281, 24 870−0504, 32 870−0550−07, 20 870−0550−09, 8 , 16 , 20 870−0557, 6 , 7
870−2055, 24 , 49
851−0022, 64
870−2062, 48 , 49 , 52 , 55
851−0048−01, 60 , 62 , 64
870−2064−01, 48
851−0048−02, 60 , 62 , 64
870−2065−03, 28 , 30 , 32 , 88 , 91
851−0048−03, 64 853−0005, 28 , 30 , 32 , 57 853−2008, 44 , 45 , 49
821−6001−01, 48
853−2010, 83
821−6001−02, 97
853−2012, 28 , 30 , 32
821−6002−02, 51
854−0006, 70
821−6002−03, 36 , 44 , 60 , 62 , 97
856−0008, 28 , 30 , 51
821−6003−03, 28 , 30 , 32 , 60 , 62 , 64
860−2053, 70
850−2020, 6 , 7 , 8 , 22
821−5004−03, 16 , 22
821−6003−02, 6 , 7 , 8 , 24 , 28 , 30 , 32 , 36 , 37 , 38 , 44 , 45 , 60 , 62 , 64 , 81 , 83 , 99 , 100
860−2010, 24 , 60 , 62 , 64 , 95
870−2054, 5 , 28 , 30 , 32 , 84
853−2006, 28 , 30 , 32
821−6003−01, 16 , 54 , 60 , 102
Page
850−2012, 39 , 40 , 60 , 62 , 64 , 95
821−5004−02, 8 , 16 , 20
821−6002−04, 64
Part No.
856−0010, 5 , 37 856−0030, 83 860−0008, 57 860−2005, 41 860−2006, 41 , 48 860−2009, 12 , 13 , 28 , 30 , 32 , 76 , 80 , 83 , 86 , 94 , 96
110
871−0010, 18 872−0019−01, 48 , 52 , 55 895−0401, 56 895−0414, 28 , 30 , 32 , 76 , 86 898−1254−25, 41 A029C090, 16 A029G313, 8 A029G975, 8 A029G977, 8 A029H243, 8 A029H247, 8 A029H251, 8 A029H255, 8 A029J872, 8
Numerical Index Part No.
Page
Part No.
A029K623, 8
A040Y083, 30
A029Z466, 30
A084Z634, 8
Page
Part No.
A029Z470, 30 A029Z634, 10 A029Z638, 10 A029Z639, 10 A029Z640, 10 A029Z642, 10 A029Z643, 10 A030B763, 35 A030B765, 34 A030C915, 24 A030C918, 24 A030C920, 24 A030C923, 24 A030G790, 34 , 35 A030G800, 34 , 35 A030H999, 90 A030L754, 90 A030Y031, 30 A030Y035, 30 A030Y039, 30 A030Y075, 30 A030Y079, 30 A030Y087, 30 A030Y093, 30 A030Y097, 30 A030Y103, 30 A030Y108, 30 A030Y112, 30 A030Y116, 30 A030Y120, 30 A032Y644, 90 A034B444, 30 A034R952, 8 A040X443, 11 A040X445, 11 A040X446, 11 A040X447, 11 A040X449, 11 A040X451, 11
111
Page
Part No.
Page
Cummins Power Generation 1400 73rd Ave. NE Minneapolis, MN 55432 USA Phone 1 763 574 5000 Toll-free 1 800 888 6626 Fax 1 763 574 5298 Email [email protected] www.cumminspower.com CumminsR, the “C” logo, and “Our energy working for you.” are trademarks of Cummins Inc. E2013 Cummins Power Generation, Inc. All rights reserved.