APW-100 Ricardo Generator Technical Specification Sheet PDF [PDF]

Zitiervorschau

TECHNICAL SPECIFICATION SHEET APW-100 100KVA RICARDO DIESEL GENERATOR SET Genset Model

APW-100

Prime Power (kw/kva) Voltage (v) Frequency (Hz) Connection: Engine Model: Net Weight (kgs)-Open Dimensions (mm)-Open

80/100 220 60 3 phase 4 wire R6105AZLDS2 1370 2300*760*1550

Standby Power(kw/kva) Rated Speed (rpm) Rated Current (A) Power Factor: Alternator Model: Net Weight (kgs)-Silent Dimensions (mm)-Silent

88/110 1800 262.4 0.8 UC274C 1960 2850*1150*1650

Voltage Available: 50Hz: 380-400-415V/220-230-240V; 60Hz: 220-380-416-440-480V/110-208-220-240V Any special voltage is also available as client’s request Prime Power: comply with GB/T2820-97(eqv.ISO8528). Genset can run unlimitedly under certain power range. One hour 10% over load in every 12 running hours is allowed; Standby Power: standby power is the limit value of maximum output for emergency use. It is off-oil power, overloading is prohibited

Standard Configuration: 

Engine: RICARDO R6105AZLDS2



Cooling Fan with fan guard and front guard



Alternator: Single bearing, IP23, H class



24V Charger



Shock Absorber



Dry Air Filter. Dual Fuel Filter. Engine Oil Filter. Coolant Filter.



MCCB Circuit Breaker



Standard Control Panel; ATS for optional



2x12V Start Battery with connecting cable



Storage Battery and battery line, Exhaust pipe, Corrugated pipe for anti-vibration, Cone Tube, Flange, Muffler



Soundproof Enclosure/Canopy for optional



Documents

Quality Assurance: 

Factory Inspection, the test items before delivery are mainly as follows: 

Each genset shall be put into commission more than 4 hours totally. They are tested on idle load, fully load and 10% overload;



The noise level is tested



All of the meters on the control panel shall be tested



The appearance of the genset and all of the label and nameplate shall be checked

TECHNICAL SPECIFICATION SHEET APW-100 

Warranty 12 months or 1000 running hours from shipment date. If the quality problem arise during the warranty period, and verified the problem is caused by our genset-body instead of external or natural reasons. (Refer to all kinds of natural disaster, shipping, loading, unloading, wrong-operation, etc), we will supply the relevant spare parts free of charge for maintenance; after the warranty period, we can supply the required spare parts for you under cost prices.

Engine Parameter: Manufacturer/Model: Aspiration: Fuel System: Cylinder numbers Displacement: Bore x Stroke Compression Ratio: Max. Power: Governing System:

RICARDO R6105AZLDS2, 4 stroke Turbocharged after cooled Direct Injection 6 cylinders 6.75 L 105 x 130 mm 17:1 143KW Mechanical Exhaust System

Exhaust Volume: Exhaust temperature: Max. Allowed Back Pressure:

15.6m³/min 600 ℃ 10 KPa Intake System

Max. Allowed Pressure: Gas Volume: Air Flow:

6.25 kPa 6.9 m³/min 152 m³/min Fuel System

100% Load (Prime): 75% Load(Prime): 50% Load (Prime):

218g/kW.h 163.5g/kW.h 109g/kW.h Lube System

Oil Capacity: Oil Consumption: Max oil Temperature (℃) Oil Pressure at rated speed:

17L ≦2.04g/kw.h 105 350 kPa Cooling system

Coolant Capacity: Thermostat: Max. Water Temperature:

23 L 82-95℃ 104℃

TECHNICAL SPECIFICATION SHEET APW-100 Alternator Parameter:

Basic Information

The alternators meet the standards of: GB755, BS5000, VDE00530, NEMAMG1-22,IED34-1,CSA22.2 and AS1350 Technical Data: Manufacturer: Phases: Connection: Bearing numbers: Power Factor: Protection Class: Altitude Condition: Excitation: Insulation class/Temp. rise class: Tel. Influence Factor TIF: Tel. Harmonic Factor THF: Steady State Voltage Regulation: Alternator Capacity: Efficiency: Cooling Air Flow:

ACEPOW UC274F 3 3 phase 4 wire, Y type 1 0.8 IP23 ≦1000M Brushless, self-excitation H/H ﹤50 ﹤2% ≦±1% 100KVA 92.4% 0.305m³/s

Genset Technical Data: Voltage Setting Range: Steady State Voltage Regulation: Transient Voltage Deviation: --100% sudden power cut: --Sudden power on Voltage Stabilization Time: --100% sudden power cut: --Sudden power on Steady State Frequency Regulation: Frequency Fluctuation Rate: Transient Frequency Deviation: --100% sudden power cut: --Sudden power on Frequency Recovery Time: --100% sudden power cut: --Sudden power on

≧±5% ≦±1% ≦+25% ≦-20% ≦ 6s ≦ 6s ≦5% ≦0.5% ≦+12% ≦-10% ≦ 5s ≦ 5s

TECHNICAL SPECIFICATION SHEET APW-100 Control System:

Standard Control Panel—HP1.0

DSE3110 4-protection panel

Model:

HP1.0

Voltage Meter



Frequency Meter



Current Meter



Water Temp. Meter



AMP Meter



Voltage Phase Switch



Hour Meter

Optional

Current Phase Switch



Oil Pressure Meter



Fuel Meter



Gen. Operating Indicator



AVR



Trans. Indicator



Key Start



Emergency Stop Switch



4 protection function-GTR17

Optional

ATS (Automatic Transfer Switch) Control Panel – HP2.0

Smartgen 6120 ATS Control Panel

Switch Box

Panel Wiring Diagram

Main Features

Deepsea 7510

Display

LED

Language

Chinese / English

Hours



Plug-pull terminal



Com port

Link

Fix Input

1

Config Input

2

Fix output

2

Config output

4

Analog Input

3

Generator Data



Engine Data



Fuel Level



Over speed



High engine temp.



Low oil pressure



Fail to start



Over voltage



Under voltage



Over current



Short circuit



Idle control

